Recent content by Auxlarry

  1. Auxlarry

    Update: Cowl air inlet, '86 1.6L, 115hp Sea Drive

    I've been running sea drives for years and have dealt with the unruly design of the mount but I have a question for those familiar with them. In normal seas she does great but in heavier seas 2-3 foot I have always had an issue when I trim down all the way to take off she has a tendency to...
  2. Auxlarry

    Water in #4 cylinder

    Just got done with a complete powerhead rebuild. .030 over bore, new pro v pistons, bearings and electrical components on an 85 115 horse crossflow. Took it out over the weekend and it ran great for about an hour, tried keeping the rpm's under 4000. It started to bog a bit and I shut it down and...
  3. Auxlarry

    Thoughts on a 2007 E115DSLSUC?

    I'm looking at a 90 Hydra Sport with this 07 engine on it!! Is it a good engine because I know some year E TECS were a problem! Thanks
  4. Auxlarry

    Fuel Pump Question '96 115 ELPTO

    I've been questioning the output of this fuel pump and have rebuilt it but after looking at the service manual and the Mercury parts list I see a difference in the repair kits. The pic in #1 Shows the Mercury parts manual and is the one I installed. Pic #2 shows the service manual and one of the...
  5. Auxlarry

    Top speed of 96 180 Tourn Pro with 115 ELPTO

    Hi everyone!! My son just purchased a 96 180 Tournament Pro Starcraft with the Merc 115 ELPTO. the boat is in good shape and after a tune up, link and sync it runs good but it will only do about 30mph with two of us in it at 5250rpm. Is this about right for this boat? Thanks!!
  6. Auxlarry

    96 115 ELPTO Running Issue

    As I have some knowledge of Johnson/Evinrude this Mercury is new to me and I am having an issue with WOT performance. I've read that this engine is a 2+2 and I think that is where my problem lies. The engine is in good condition, compression is between 132-135 on all four cylinders, have great...
  7. Auxlarry

    Fuel Pump-Help

    I'm at Anna Maria Island for a few days, got my boat at Keyes Marina and my fuel pump went out and can't find the parts!! Anyone in the area have any or know where to find them. 1990 115hp Johnson NON VRO. Thanks, Larry
  8. Auxlarry

    Tilt/Trim Bleeding Down

    Hi Everyone!! My son just purchased a 1996 Starcraft Tournament 180 with a 115 4 cyl Merc on it. Engine runs great with good compression numbers but the tilt/trim bleeds down and I'm getting ready to rebuild the unit. I checked on the Merc parts page and found the following kits, 809873A1 -...
  9. Auxlarry

    Timing for 85 OMC Sea Drive 1.6L 115HP, (2BBLCO)

    What is the correct timing (btdc) for this engine? I have it set at 24 btdc and want to make sure before I put it back together and run it that the timing is correct!! Thanks!!
  10. Auxlarry

    Burned Piston, 85 OMC 1.6 L 115hp, 2BBLCO

    Had the boat out and after about an hour of wot running she just slowed down and quit, no overheat alarm, nothing! Got it back home and check compression and found the lower starboard cyl at 53 psi. Pulled it down today and found the burned piston and checked the overheat circuit and it is...
  11. Auxlarry

    Powerhead Question

    I just acquired an older V4 crossflow powerhead on an '86 Wellcraft which is supposed to be 115hp. When I look up the model in brp parts I noticed it had at least a '88 or later ignition system on it (1 powerpack). This is a Sea Drive model 2BBXCO but it also has carbs with plastic bowls. The...
  12. Auxlarry

    Part for '85 1.6L Sea Drive

    I am looking for a part for my Sea Drive. The part is 0983641, it is the Anchor Assembly for the Shift and Throttle cable that is mounted under the cowl and attached to the air box. I know the part is obsolete and I have been trying to locate one through the used market but can't seem to find...
  13. Auxlarry

    Replacement Fuel Pump for VRO

    I'm looking for a fuel pump for my '85 115hp Evinrude. I have been running premix for a few years and just found the VRO pump cracked and leaking fuel. What is a good replacement non-VRO pump?? Thanks, Larry
  14. Auxlarry

    '85 115hp Evinrude - Weak Spark on Port Cylinders

    I think I created a monster!! My engine hadn't been run in a year or so and when I got it all prepped (including new water pump) it only fired up on the right hand bank of cylinders. I did the normal trouble shooting, power pack and coil swap and had the same results. Well, the wiring under the...
  15. Auxlarry

    Steering link for twin 250 Yamaha

    The steering connecting link for my twin 250's broke the bearing on the port engine. Anyone know where I can find one? It looks like a S.S. rod end bearing! Thanks! Larry
See more
Top