Recent content by Disco44

  1. Disco44

    1993 Mercury 60 hp 2 stroke has cough/misfire/sputter!

    Thanks for the reply but yes I beleve it was, adjusted the mixture screws a little and ran for about 20 min without a cough, so maybe I have it dialed in, dropping for a test run this afternoon.
  2. Disco44

    1993 Mercury 60 hp 2 stroke has cough/misfire/sputter!

    I need some help trying to figure out what is going on with my merc as it is driving my nuts not being able to figure this out. Long story short finally had time to clean carbs and attempt to get running for the last part of summer, well all good got it timed, and rpms within spec but dropped...
  3. Disco44

    1993 60 hp 2 stoke has zero fire!

    Well I guess I'm at the "throw money" stage with this motor! Just rebuilt and put back together and would fire but bottom carb float had a crack and was spewing gas, got that replaced and fired right up, a little rough, but did fire. Before I could adjust anything it died and has had no spark...
  4. Disco44

    Rebuilt 60hp 2 stroke idles high

    After getting everything back together and hooked back up I could get it start but it idles like it's at mid throttle. I adjusted the idle screw on carbs which helped a bit but still high. I know the linkage can adjusted but manual not so clear in how this is done, any pointers?
  5. Disco44

    60 hp powerhead tear down pics

    Cracked open my 93 60hp 2 stroke to investigate knocking and low compression in the top cylinder and found this, I would say that piston is toast! The other 2 seem ok, any thoughts or input?
  6. Disco44

    Help with 1993 60hp rebuild

    Well just as the title says, I need to get my 60 hp back on the water and had some questions before I start the rebuild. The reason I'm having crack it open is the oil injection hose crapped out and now too cylinder has low compression on top of nice knock. The other 2 cylinders still have great...
  7. Disco44

    93 60 HP 2 stroke overcharging, which solution to start with?

    I've had this motor for about 2 years and just normal maint. has been required but went out last weekend and noticed the volt meter pegged out on 17, as I gave it more throttle it would bounce back to 14 then shoot back up to 17. I have read and searched about this issue and read anywhere from...
  8. Disco44

    1993 60 hp carb problems

    I have a 1993 60 hp OD187399 with triple carbs, I started noticing gas/oil runnning down the lower unit after pulling it out of the water and puddling up in cover. When I tilt the motor up the bottom carb starts dripping gas that never stops. I thought float could be stuck so I turned gas off...
  9. Disco44

    New Stereo will not turn off?

    Just had a new stereo installed in my pontoon boat but even if you turn the head off and the display shuts down, music still playing? It is suppose to be wired to a on/off switch but even if you turn the kill switch off on the dash it is still playing and drawing power from the battery which...
  10. Disco44

    Trim ?

    I have 1993 Mercury 60 hp on a 24' Monark pontoon boat, when I pull boat out of water on trailer and trim motor up by the time I get home the motor is trimmed down?? Is this low hyd fluid or any help?
  11. Disco44

    No start, well nothing really!

    I thought I had a switch problem but replaced that and I still have nothing, I have lights, radio, depth finder everything but power to gauges and motor. Checked the wires coming to switch and they all have juice, battery new and leads clean, all fuses replaced, checked 20amp on motor all is...
  12. Disco44

    Chasing short

    I have obviously got a shaort that I can not seem to locate! It's a 93 Monark sun spa 240 with a 60 hp Merc, the switch and trim will go blank but everything else is still powered, even the trim at the motor but will eventually come around and "click" and everything is all good. There is a 2A...
See more
Top