I've got a 17' Aquasport with a 93' 115 Merc. The motor has a hyrofoil fin bolted to it. I like the way the fin pulls the bow down into the water but I feel it pulls it down too far, especially at high speeds. Has anyone ever tried cutting a small portion off each side of a fin to lessen it's...
I need to put a new cushion in my cooler seat, it's worn out and doesn't offer much support. Is there a special type of foam cushion that I should use that offers max. cushioning properties?
I have a 93' 115 Merc 4 cyl. on a 17' Aquasport. As you can see from this pic I need to replace my control cables. They are worn where the engine cover goes over them.<br /><br /> <br /><br />I know that the cables need to have a loop in them for free movement on turning and tilting the motor...
After being so frustrated with my water pump install try (see my other post) I decided to try saving my ego by tackling another project, rebuilding my fuel pump. Everything went well and my primer bulb pumps tighter than it ever has. My motor is a 1993 115hp 4cyl.<br /><br />The question I have...
1993 115hp 4cyl<br />I replaced my water pump yesterday, my first time on an outboard, and think I may have screwed it up. When I fired the motor up today at the ramp water was leaking out where the shift shaft goes into the lower unit. Here's a pic that shows this.<br /><br /> <br /><br />I...
I have a 1993 115hp 4 cyl. I was doing a little reading on old posts and found some discussions about Merc oil injection systems. I sounded to me that a few of you don't hold much faith in the reliability of the system on the older engines. My question is if you owned my 1993 motor would you do...
I have a 1993 115hp 4cyl. on a 17' Aquasport. I think it may be propped wrong but would like some advice before I try to change anything.<br /><br />At full WOT I can turn 6300 rpm. I know this is too high and am fearfull of doing some damage. In the past I have just been carefull to not open...
Hi all, I figured this would be a good place to ask this question since this board helped me with my motor a few months ago.<br /><br />A friend of mine had her purse stolen yesterday. One of the items in her purse was her boat keys and she doesn't have a spare set. How can she go about getting...
I recently purchased a used boat that has a 1993 Merc 115 4cyl motor on it. The serial # is OD190240. The motor seems to have been maintained well, it's very clean and everything appears to have a good amount of lube. I'm planning to replace the water pump and thermostat just for peace of mind...
