Recent content by GoTTwins

  1. G

    2004 DI 225hp hesitating at mid range

    2004 225DI hesitates at mid range only Model E225FCXSRB Serial 05064993 Engine runs fine below about 1500rpm's, in between 1500 and 3,000rpm's it hesitates really bad like fuel is getting cut off and then above 3,000rpms it runs beautiful. No codes. In neutral it will not happen, only if under...
  2. G

    Power Distribution Panel Questions

    Model E225FCXSRB Serial 05064993 Ive been having a starting issue lately. Turns over but sometimes will not start. Then yesterday my trim motor quit on me. I've traced it to the PDP. Relays are all good/fuses all good. I even switched PDP's between engines and same problem happens with other...
  3. G

    2004 225 DI Stutter

    2004 225 DI Model-E225FPXSRB Serial-05036690 I cannot keep the engine rpm's between approximately 2300 and 2800. The engine appears to stutter or cut out in this range. I must go from 2300 straight to 3000rpm's. It don't stall it just jumps/stutters whatever you wanna call it. Runs smooth at all...
  4. G

    Thermostat O Ring part # 2004 225DI

    Looking for the thermostat O Ring part number that seals the cover please. Engine serial # 05036690 Thanks, Dave Ok I believe I found the part number. 0301917 ?? How about the drain plug nylon washer part # ????
  5. G

    Starting Issue

    Friends boat! 2001 Evinrudes, 250 Fitch. serial number#G04886638, model #E250FPXSIF on the problem engine. It starts fine the first time and everytime after being run at lower (less than 1000) rpm's. If it is ran at higher RPM's 2000 and up for even a short time when he shuts it down it will...
  6. G

    loose throttle handles

    My buddy has twin 2005 135 HP Ev's. The throttle handles are very loose, meaning they rock side to side. They are fine holding at all speeds with your hands off the throttles so that is not the issue. He said he took off the BRP round cover on the side of each throttle and tried to tighten that...
  7. G

    F115 Water Pump change

    Changing the water pump on my dad's 2003 f115 four stroke today. Rodbolt, I did a search on your posts and could not find the one with "lifting the shaft while seating the collar". Can u elaborate a little please or direct me to some tips u gave on changing this pump. Much appreciated, Dave
  8. G

    Good price?

    on Ebay 2003 Evinrude 135HP DI, 600 hrs, 2 years left on warranty asking 3500$. Good price????
  9. G

    Extended warranty

    My original 3yr warranty on my 2004 ev 225DI expired last month and I'm now on the 4yr "Premium Marine Protection" extended warranty that I had purchased from the evinrude dealer. After getting a "no oil" alarm I dropped it off at the local evinrude dealer who stated the oil pump needs...
  10. G

    Exhaust Leak???

    2004 225 DI. Black substance running out of the area between the lower unit and the midsection. Dave
  11. G

    Starting Problem

    I have twin 2004 225DIs Ev's. I turn the key to energize the fuel circulation pump for 10 seconds and then fire it up and both engines start and run on the first shot in any temperature(Usually). My buddy has twin 135 DI's 2003 and his engines always start on the first try in any temperature...
  12. G

    Fuel problem???

    After 2 months of my dealer/mechanic troubleshooting still don't know what's causing my problems. Twin 2004 EV 225's Direct Injections. 135 hrs last year with no problems. Winterized and stored for 4 monthes. New tank of gas to start off season and both engines start to stall when coming down to...
  13. G

    Bad Gas???

    Twin 2004 225 ev DI's. 138 hrs. Ran great at end of season (Dec). Gave it to the dealer to winterize and store with about 30-40 gallons left (20 in each tank, Tanks hold 129 each. Computer readout at end of season says no problems with engines. Compression checks all good, no water, etc. Added...
  14. G

    Gap Setting??

    2004 225HP DI's Evinrudes????Plug is Champion QC12PEP.
See more
Top