Recent content by Oday20

  1. O

    2006 Nissan 9.8 NFS9.8A3 Revival

    Alright, I installed a water pump rebuild kit and also the plastic water pump body which was damaged. Reassembled. Started right up and now dripping from pee hole. The old water pump was completely shot...the impeller was trashed and the upper plastic water pump housing had gotten so hot it...
  2. O

    2006 Nissan 9.8 NFS9.8A3 Revival

    Thanks!
  3. O

    2006 Nissan 9.8 NFS9.8A3 Revival

    Ordered a tohatsu water pump kit, cowl seal and anode. Looking forward to mounting this now apparently functional motor on my sailboat. What is best adhesive for attaching cowl seal to the plastic cowl? Looks like PO hit an oyster rock and prop is slightly dented. I plan to, for now, just...
  4. O

    2006 Nissan 9.8 NFS9.8A3 Revival

    Watched videos on replacing water pump impeller. Seems pretty straight forward. Going to order a waterpump repair kit from tohatsu. I'll wait until tomorrow in case maybe someone has a better idea.
  5. O

    2006 Nissan 9.8 NFS9.8A3 Revival

    Ok, replaced the plugs. It fired right up. Amazing. I was able to adjust the idle pretty low. Starts immediately pull or electric start. Only problem is that I don't see any water coming from the cooling water check port. I never let it run over 10 or 15 seconds. How long should I let the...
  6. O

    2006 Nissan 9.8 NFS9.8A3 Revival

    Thank you
  7. O

    2006 Nissan 9.8 NFS9.8A3 Revival

    I purchased a sparkplug tester and verified I have spark from both sparkplug wires so the coil seems to be working. I tried to crank and got a little intermittent firing on one or two occasions. I plugs were dirty but not as oil fouled as I thought I remembered. I'll replace them anyway and...
  8. O

    2006 Nissan 9.8 NFS9.8A3 Revival

    I found this Tohatsu service manual online which is for the same outboard (as far as I can tell). Much easier to read than the paper manual I have. I could not make out the wiring diagram symbols on in the paper manual I have. With this electronic copy the imagery was clear and helped me...
  9. O

    2006 Nissan 9.8 NFS9.8A3 Revival

    Got this motor with a sailboat. Working through it to see if I can get it to run. I finally got my Nissan electric start 9.8 to crank (special thanks pvanv. Yes it was simple...had the B- on the solenoid rather than to a grounding point) . Now on to getting it to start. I put some gas in the...
See more
Top