Thanks for the pictures and information, looks like it shouldn’t be that hard to take apart, but what about putting it back together? Will I have trouble getting things lined up like the driveshaft and can I leave lower unit on cradle and lift the top part off myself?
Thanks to both of you for this latest advice, I can see that the surfaces where the rubber gasket (O ring) seal is pretty rough and with the amount of marine growth on outside of outdrive and boat from being in saltwater pretty good guess there are animals living inside water pick up holes and...
looks as if the rubber seal where the two come together may not be enough or flat enough to really seal, should I clean surfaces and use something like 5200 to keep water in and air out?
I’m back again and still have same problem, thought it was fixed Sunday when dunked boat on trailer at launch ramp and everything was working, pulled off hose to heat exchanger then hose from exchanger and was getting good raw water flow. Launched boat and headed to my slip at marina when...
Went and spoke to marine mechanic today, told me a plastic water tube near top inside of outdrive breaks on Volvo Penta often allowing air inside keeping water from flowing. He also said to test it by putting duck tape over pickup holes on sides of outdrive and run water through the inlet hose...
My boat does sit in salt water at marina and when pulled outdrive was covered with tiny white worm like growth even thought painted with anti-fouling paint. Back flushed from inside out through outdrive, let water run for five minutes but saw no signs of anything being flushed out.
Yes I have tried having muffs on, hose disconnected at pump and not a drop with garden hose on at different pressure even at full, (even bought new muffs thinking old ones may not be holding tight enough). The water flows freely with garden hose inside boat hooked to inlet hose out through...
My 1999 Monterey 26.2 Cruiser overheats. Pulled boat from water to replace leaking raw water pump believing that was causing overheating. Long story short with muffs on outdrive can not get water up to water pump, when I put garden hose inside boat hooked to hose that connects to inlet of pump...
