Search results

  1. Z

    50merc coil question

    Merc 50 efi 0t661230 pic one shows coils and wires that should be on it pic 2 shows what’s on it. Would this make engine run bad?
  2. Z

    03 4 stroke 50hp not running

    Got an 03 4stroke 50hp efi not running right. Very rough idle and dies out when throttle applied. Some times it will idle fine when first started for a second or two but rough again. I have ruled out bad gas with an external tank with fresh fuel, New fuel filter bowl assy, Spark plugs and wires...
  3. Z

    Need lower unit

    I’ve got a 75 johnson v4 85hp engine in need of a lower unit. What years and hp will work with this engine
  4. Z

    help me with year and model of this boat

    just picked up this boat i believe it is a starcraft american but not sure and not sure what year it is either. Also anyone know where i can get parts for this hull?
  5. Z

    89 30 hp not running right

    Ok got a 89 30hp e30elced with cdi ignition with controls for throttle and shift at helm. Is the plate supposed to rotate under the flywheel when the throttle is advanced? It does not and this is the first evinrude I have worked on that it does not move. There is just a small rod with a set...
  6. Z

    force 40 red stator no spark

    no spark on force 40hp. red stator with stator adapter box. disconnected black/yellow wire no spark. Disconnected yellow wires to rectifier no spark. 668 ohms between white and green stator wires. no reading from either green/white wire from stator to ground. blue wire from stator adapter box...
  7. Z

    starboard cyls no spark

    88 johnson v4 120hp at full throttle eng would die out and start right back up again. now eng died out and would not start again. no spark on the starboard cyls. Top cyl has spark for two fires then nothing bottom cyl is totaly dead. Sound like a power pack?
  8. Z

    88 120 v4 at high rpm knock/clunk sound then dies

    So Im working on a friends boat. He said the rpms wernt as high as they ues to be and its shutting down. after talking with him he said it was runnin around 6000 book says 4500-5500. So did compression test top two 130 bottom two 120psi, plugs looked good, cleaned carbs, put it in the water and...
  9. Z

    t25tlra wont start in morning

    Got a t25tlra 4-stroke that is hard to start in the morning but after that it runs fine all day. I have replaced the fuel pump, rebuilt carb, and replaced the prime start solenoid. What else am I missing here?? Eng is on a pontoon boat and the fuel tank is above the eng.
  10. Z

    what happens if timing is off

    Lets say the timing of the cams to crank shaft is 180 out on a 115hp merc four stroke outboard. What damage will happen?
  11. Z

    need seals for my trim cyl

    I have a 1987-2006 75-125 HP. Single ram 3 wire system, the seal where rhe rod comes ot of the cyl is leaking. Where can I find this seal or a seal kit?
  12. Z

    what year is this motor

    60hp mercury power tilt 0B358051
  13. Z

    what year lower units will fit this eng

    What year and size engs have lower units that will fit a 1997 ELPT0 SN-0G527011
  14. Z

    Help me find tools and parts

    I need a Driveshaftholder tool for a 1997 90elpt0 SN-0G527011 anyone know where to get one. Also I need some parts for the lower unit, shift cam, fwd gear, rev gear clutch, water pump kit and all seals to put the lower unit back together. Where is a good place to get these parts.
  15. Z

    help me find tools and parts

    I pulled the lower unit apart on the 1997 90elpt0 SN-0G527011 and its busted. I need the drive shaft holder tool the one that goes over the splines to get the nut off the pinion gear, where can I get one? Also need fwd gear, rev gear, clutch, shift cam, waterpump kit, and all the seals to...
  16. Z

    90elpto rev problem not controls or cable

    Friend of mine let someone use his boat at a family outing and the guy revved the eng up and slammed it into rev. Now it won?t fully engage into rev, out of the water it will spin in rev but in the water it will not move the boat in rev. Checked the linkage in the control box, and disconnected...
  17. Z

    please help looking for stator

    Ok got a 95 40hp 4cyl mercury outboard and the stator and triger are fried. I have been to a few dealers and online parts places and they all say the stator is no longer made. So what am I to do now? Anyone know where I can find a new or used stator for this motor, part#398-818535A17
  18. Z

    oil warning module no spark condition

    If this module was bad will you get a no spark condition? I had no spark found regulator melted. Replace regulator and it ran. I shut it down after a minute or two and tried to start it back up and she won?t start. Let it sit for an hour and got it to kick off the starter once then nothing...
  19. Z

    help me a starting problem

    40hp 4cyl merc would not start. Found that the voltage regulator as burnt up. Replaced it and she ran, shut it down then would not start again, no spark. Whats up here? Can someone tell me if you put an ohm meter on the black wire of the regulator and the other lead to each other wire which...
  20. Z

    help with stator

    Ok I have a mid 90's 40hp evin with no spark, and an 82 70hp evin thats locked up. I think the 40hp has a bad stator, can I use the stator out of the 70hp or are they different.
Top