Search results

  1. K

    2005 4.3 liter Mercruiser ignition trouble

    Agree that ‘a’ is irrelevant. Now I know. Summary: 1) followed trouble shooting flow chart to -replace distributor sensor - so I did. Cap/rotor and sensor all replaced. 2) low voltage at +terminal on coil while cranking. 12v with key on. 3) ‘I’ terminal at keyswitch has 12 volts while...
  2. K

    2005 4.3 liter Mercruiser ignition trouble

    That’s when I had my head up my ass and I was checking the wrong purple. I should have said every connection except A gets power when the key is turned to start. Currently have power at the switch (I), not at the coil.
  3. K

    2005 4.3 liter Mercruiser ignition trouble

    Not my boat but it looks very similar to this. Mine has a pad behind it that I guess is for your arm.
  4. K

    2005 4.3 liter Mercruiser ignition trouble

    I bet you are right but I don’t think that will tell me where the problem is. I now know I’m losing power somewhere between the switch and the coil. That kill switch seems awful suspect? Does anyone have info on how to get it out without wrecking it.
  5. K

    2005 4.3 liter Mercruiser ignition trouble

    The switch must kill the accessories to save voltage while starting the engine
  6. K

    2005 4.3 liter Mercruiser ignition trouble

    You can see the purple wire I should have been checking in the back. The red wire that is coming off the same lead goes to the warning squealer.
  7. K

    2005 4.3 liter Mercruiser ignition trouble

    I was today years old when I learned (I) is for ignition. 🤦‍♂️ Been testing the wrong lead. The A connection also has a purple wire but it’s purple/red. The (I) connection almost looks maroon but either way I’m a dumbass and back to checking connections and grounds.
  8. K

    2005 4.3 liter Mercruiser ignition trouble

    Yeah. Every wire except the purple has or gets 12 volts when the key is turned to start. To further clarify, every single wire is disconnected except the power.
  9. K

    2005 4.3 liter Mercruiser ignition trouble

    To clarify. The supply wire never loses power. The tab where the purple wire is supposed to be connected is what loses power when the key is turned to start
  10. K

    2005 4.3 liter Mercruiser ignition trouble

    Please read the post again. That’s not where the power loss is.
  11. K

    2005 4.3 liter Mercruiser ignition trouble

    New switch same problem. I have every wire disconnected except red/purple supply. Turning key to start results in zero voltage at the purple wire tab. So this either means the new switch is junk or it’s not supposed to be supplying power to that wire during cranking
  12. K

    2005 4.3 liter Mercruiser ignition trouble

    Ok. I get it now. I’m so used to black and white I think all the colors were scrambling my brain. But it’s a switch so I need to check both sides, which I have now done. The supply on the ignition maintains 12 volts while cranking the purple wire does not.
  13. K

    2005 4.3 liter Mercruiser ignition trouble

    I did pull the connector. There is no corrosion of any kind. It looks brand new. For some context this boat has spent most of its life in a garage that never gets below freezing in the winter. Most if not all connections have little to no corrosion. I will check all that I can find but a “bad...
  14. K

    2005 4.3 liter Mercruiser ignition trouble

    Anyone have a diagram of this? I need a map
  15. K

    2005 4.3 liter Mercruiser ignition trouble

    10 pin engine connector visually looks immaculate. Not sure how or what to check with volt meter.
  16. K

    2005 4.3 liter Mercruiser ignition trouble

    What’s the voltage drop test that I haven’t done. Where else am I checking it? Is there something between the ignition switch and the coil? I was assuming it was the same purple wire between ignition switch and coil which was telling me the switch was bad.
  17. K

    2005 4.3 liter Mercruiser ignition trouble

    I checked at the coil already. I thought that was why they had me check the ignition switch. 12V with key on 4V while cranking. What is the resistance across connections supposed to be?
  18. K

    2005 4.3 liter Mercruiser ignition trouble

    I did check battery with volt meter while cranking but no load test other than that. I only have an analog volt meter but it did not go below 11 volts
  19. K

    2005 4.3 liter Mercruiser ignition trouble

    12 volts at purple wire with key on goes down to nothing while cranking. Seems like a problem.
  20. K

    2005 4.3 liter Mercruiser ignition trouble

    No fuel injection on this model but I think it was available at the time. My issue is for sure spark not fuel.
Top