Search results

  1. Bt Doctur

    No engine alarms. Can’t find anything in service manual.

    a horn or buzzer will be under the helm. They work on a "ground" . When the temp or oil ground ,the alarm sounds. Switches usually located on the therm housing or intake manifold, oil near the oil pressure sender for the gauge
  2. Bt Doctur

    Brown dust on exhaust and spark plug look

    considering spark plug threads never go into a chamber I`m guessing your using the wrong plugs, extended reach instead of standard length
  3. Bt Doctur

    Alpha One power steering - how to remove cable?

    file:///C:/Users/Edeward%20J/Downloads/_06__Drives_R-A1_83-90.pdf
  4. Bt Doctur

    Alpha One power steering - how to remove cable?

  5. Bt Doctur

    Choke setting - error in manual?

    ignore any settings, adjust the choke plate to close on a 1/8 drill bit
  6. Bt Doctur

    Alpha One power steering - how to remove cable?

    carefully cut the tube off the cable and replace the tube , corrosion is holding it in place OR replace the cable and tube
  7. Bt Doctur

    U-joint seized into gimbal bearing

    This is after the fact but for those who cant pull a drive with the lift and drop method reattach the rams, cut pieces of 2 x 4 5,6,7,8 inches long and place between the top of the housing and transom. CAREFULLY use the trim/trailer button to raise the drive and force the drive off adding...
  8. Bt Doctur

    Raw Water Pump Priming

    wrong impeller if it all worked before
  9. Bt Doctur

    Mercruiser engine year

    96 to 97
  10. Bt Doctur

    U-joint seized into gimbal bearing

    gimbal bearing is rusted too ,it will come out with the shaft. cable and come-along or chain hoist worst case, cut the shaft behind engine, pull engine ,drive out shaft and bearing
  11. Bt Doctur

    Alpha 1 Gen 2 Weak Link

    The weakest link is operator malfunction
  12. Bt Doctur

    350 mercruiser stalling when shifted into gear

    pull the drive and inspect everything, may just be some corrosion or worst case lower cable replacement
  13. Bt Doctur

    3.7 mercrusier 165 horse engine

    did you rep[lace the starter and what one did you use a 470 being a rear entry stater comes in both rotations. with rear entry starters a standard rotation engine uses a reverse rotation starter
  14. Bt Doctur

    Fuel Pump Diaphragm Rupture Hose Type?

    if thats a vac fitting on the lower left of the carb, its not marine
  15. Bt Doctur

    Need help removing mc-1 drive

    that only applies if taking the unit apart, not for removal. 2 things, very bad alignment or a rusted gimbal bearing DO NOT PRY ANYWHERE WITH ANYTHING reattach the cylinders, cut 4 or 5 pieces of 2 x 4 3,4,5,6 inches long place wood between the top of the housing and transom CAREFULLY hit...
  16. Bt Doctur

    Mercarb 2 barrel TKS jet sizes?

    would have been bettor off with a standard 2 barrel
  17. Bt Doctur

    Alpha One Gen 1 transom assembly seal

    adhesive and masking tape until it sets, nothing on the transom side , then carefully install the housing
  18. Bt Doctur

    2008 4.3 ltr. TKS diesels when turning off

    10 oz of plain water poured slowly into the carb will vaporize carbon deposits in the engine. Other than that check the timing and drop the idle some more and enrichen the idle mix. May have to get the tool or remove the anti-tamper device
  19. Bt Doctur

    3.0l oil drain hose leak

    or this
  20. Bt Doctur

    3.0l oil drain hose leak

    heres one type
Top