Search results

  1. S

    1982 erude 35 hp spark issues?

    I've been tinkering with this motor for the past couple of weeks and can't get it running right. Tonight I checked the compression with a rented compression tester, and got 70 psi on both cylinders after warming it up. The way the male end fit into the plug opening and where the "bolt" head of...
  2. S

    82 Erude 35 HP w/ no water flow

    Not sure where to go from here . . . I picked this motor up cheap a couple weeks ago, and have gotten it running, but can't seem to get water flow. It'll idle for 3-4 minutes, then gets hot and stalls. So, I checked the impeller. I didn't find the pin (maybe I dropped it) so replaced that...
  3. S

    1975 25 hp Gear noise

    Greetings, I just finished rebuilding my lower unit due to a worn clutch dog and fwd gear. I bought a new clutch dog, and then used a good salvage fwd gear from a gear set I bought. I reused the pinion gear and the reverse gear from my motor as they looked to be in better shape than the ones...
  4. S

    72 Johnson 50HP Hard Cranking

    Greetings, I bought a boat that came with one of these motors. I went with the deal primarily for the hull and troller, but thought I'd see if I could resell this motor as a runner. Well, I've run into a couple snags from the get go. I can't get the motor to crank over with any speed. I...
  5. S

    '74 15 hp Johnson, Water flow question, w/ video

    Greetings, I just replaced the impeller in the water pump on my motor. My question is: Where does the water normally exit the motor? There's water running out of a couple spots up the leg, near the swivels, and then one leaking from a drain hole in the extension piece. Are these normal...
  6. S

    Did I kill my motor?

    Well, I seem to be able to screw just about anything up. I pulled my lower unit off my 1974 25 hp Johnson a couple days ago to check the dog and the gears, and I apparently didn't get the water line back in the right place. I was out hunting this morning and it overheated and died. :(:(:(:(:(...
  7. S

    1975 25 hp johnson clutch dog

    Greetings: I have a few questions. From previous advice I've gotten, it was assumed the I have a bad clutch dog. The motor tends to pop out of gear when under power in forward, and has now started to "skip"; it loses power for a split second. I was able deal with the problem for a short...
  8. S

    1975 25 HP Johnson w/ issues

    Greetings, This is an amazing website. Incredibly helpful. I have the above motor. I bought it very recently to duck hunt w/ and have had trouble getting it to function properly. There are two issues: 1: It starts pretty well w/ the electric choke engaged, and will idle with the manual...
  9. S

    Prop bent too much to function?

    Greetings. Situation: I recently bought a boat with a early 70's 25 HP Johnson. I got it for a good price ($450 boat, motor, trailer, trolling motor), so didn't use it on the water prior to purchase. In my inaugural voyage to give it a test spin, some idiot (not mentioning any names...
Top