Search results

  1. W

    2002 200hp efi saltwater water in cyl #6

    serial # OT556519 engine ran fine all last year , when taking it to boat ramp at end of season in no wake zone (about 10 min ride) notice temp gauge going up , no alarm sounded and no sign of over heating. where i keep boat in winter i hooked up garden hose (not muffs) and flushed with water...
  2. W

    water pump and shift shaft position

    motor is a 2002 200 hp efi serial # ot 556519 , i replaced water pump and did not read the shift shaft set up as in the stickey above , just left control in neutral . do i have to take apart again or is there a way to check to be sure it's right . first time doing a mercury
  3. W

    ddt for 2002 200hp efi

    looking to buy a ddt , talked to owner on the phone and he couldn't find part number on it , my service manual say's it should be 91-823686a2 , but he did have the right software for it , number 91-880118a03 , as for reference manual , my manual say's part number 90-8811204--1 or 90-881204003 ...
  4. W

    2002 200 efi priming oil pump

    ot556519 replacing oil hose from remote tank to motor because of leak , I have factory service manual which says I should prime oil pump if hose runs out of oil . The manual says I need DDT to do it the right way. Is there any other way to do this ? The manual also has whats called shift switch...
  5. W

    is there a differance between oil line and fuel line

    2002 200hp efi , rubber oil line from remote 2 stroke oil tank to motor needs to be replaced , is there a special hose for oil or just use fuel line ? also what would the i.d. be , I measured 1/4 inch , does that sound right ? Thank You
  6. W

    2002 200 efi nopower to key

    ot556519 no power to key at all , on motor there is a fuse holder with 4 fuses , the 20 amp fuse that is for main power relay,remote control harness and power trim has no power to either side of fuse with key on, nor does another 20 amp fuse for ignition coils.the other 2 fuses get power...
  7. W

    2003 200hp efi compression check

    looking to buy a boat with a 2003 mercury 200hp efi , want to do compression check, and have only done one on a carbed 3 cyl . do I have to pull a fuse for fuel pump, if so where is it? also do I ground plugs or can I just pull emergency lanyard , throttle wide open ? any thing you can suggest...
  8. W

    1987 70 hp carb rebuild

    j70elcur rebuilding carb but mine is different than parts look up diagram , I have a orifice at top of carb that's not on diagram , but is on a 1990 j70elesb diagram # 15 part #0335014, same part for engines from 1989 to 1993 , called a slowspeed needle valve , would I be alright to remove and...
  9. W

    70hp johnson year and vro alarm test

    model # J70ELCUR and how do you test vro alarm. Bought boat last year and everything worked fine, would just like to check it out before putting in water. Also I get no chirp when the key is turned on,and I have to push key in (choke) to shut off,but theres been no proplem with that. Thank You
  10. W

    wahoo bilge

    I have a 1987 14'4" wahoo that i bought last year. This week i was washing it out in my driveway with all the drain plugs out, and all the water that drained out, came out of the center drain plug at the lowest point of the transom which would be under water if the boat was in the water. I read...
  11. W

    boat dies, is it my coils?

    motor is an evinrude 115hp. v4. it takes about 15-20 mins. to get out of my harbor (no wake zone) about half way out the motor sounds like it loses a cyl. (gets a little shakey, losses power) sometimes it stay's that way, sometimes after 30 sec.- 1min., more or less it will perk right up and...
  12. W

    what year is this old johnson super sea horse and what should I do before I start it

    the model # is v4sl 12s serial # 21444458 taken off the metal tag attached to the motor, it also states it's a 75hp. I have a 1964 grady white 19' pacific and would like to put an original engine on it if this is one.When I bought this boat in 2000, this engine was on an old thompson that I had...
  13. W

    1998 crownline 210ccr

    hi, new to iboats and love it.looking for my second boat and saw this ad tell me what you think. 1998 crownline 210ccr cuddy cabin,5.7 mercrusier 150 hrs.like new,sink,stove,full canvas,porta-potti, cd stereo,$13,500.00. I want a cuddy with I/O and 22' or under,any suggestions. Boat will be...
Top