Search results

  1. gator fan josh

    2000 3.0 Hydrolock

    I have a 2000 3.0 GSPEFS and have had two incidents with hydrolock. Last time was last year and I suspected the riser gasket was at fault. Happened again forst outing this year. Both times exhaust manifold has water in it. I did the acetone test to check for cracks but it passed. Both times...
  2. gator fan josh

    3.0 GS no spark

    I have a 2000 volvo 3.0gspefs and the engine dies whike out last year on the water and I haven't been able to get started since. I have narrowed it down to ignition because I get no/intermittent spark. I have replaced coil, cap, rotor, plugs, wires, and ignition module. The pickup coil ohms...
  3. gator fan josh

    3.0GS Starter Problems

    Having trouble with my starter on my 2000 VP 3.0GSPEFS. Last week I was out and noticed the starter was making a grinding noise. So I pulled the starter and it appeared that the ends of the pinion gear was worn. I had the starter rebuilt by the local recommended shop. I put the starter back...
  4. gator fan josh

    Volvo Penta SX-M Bellows and Gimbal Bearing Install Step-By-Step

    I bought a 2000 Four Winns Horizon last year that had a blown head gasket. After three head gaskets finding that the timing module and pick-up coil in the distributor where bad, the final thing I had left was to change the bellows and replace the gimbal bearing. I decided to document it the...
  5. gator fan josh

    3.0 Throttle Question

    Volvo Penta 3.0GSPEFS SX-M Outdrive Finally got my boat back from the mechanic after replacing the ignition module and pickup coil. Engine seems to run great, however when I am at idle or fast idle and I try to accelerate slowly to get up on plane the engine speeds up for a short amount of...
  6. gator fan josh

    Grease gimbal bearing

    Does anyone know how to grease my gimbal bearing? The Transom isn't flat and there isn't any clearance to get a grease gun on there, even with a flexible hose
  7. gator fan josh

    Volvo Penta 3.0 GS Keeps Blowing Head Gasket

    Boat information: 2000 Four Winns 170 Horizon 3.0 Volvo Penta GS Volvo penta SX-M outdrive. I bought this boat last October knowing that the head gasket was blown. I finally figured out the cause of the blown gasket was the raw water pump housing tubes had separated from the housing allowing...
  8. gator fan josh

    2000 Volvo Penta 3.0 GS Raw water pump bracket

    Hello, I just purchased a used 2000 Four Winns 170 with a 3.0L Volvo Penta GS and I am replacing the raw water pump impeller before storage. My question is my motor does not seem to have a bracket on the front of the pump to keep the pump static while the serpentine belt is rotating. My...
Top