Search results

  1. B

    Suzuki shift problem

    Have a 2003 suzuki 225 dt counter rotation that has a problem shifting into forward. It works some of the time and when it doesn't I shift it into reverse then back into forward and it works. This does not happen every time just once in a while. When looking at the shifter under the cover it...
  2. B

    Timlemons question

    I have the same thing on my DF 140 Suzuki with the 500 rpm drop and have tried everything. Did you fix yours and how?
  3. B

    Lakensea help please

    I have a 04 Suzuki DF140. Noticed on another forum you refered to the neutral switch on the engine being stuck. Please explain where it is and what to do. I've tried everything else and it still drops about 500 rpm's at 4000 then speeds up. Even tried a remote tank hooked direct to the fuel...
  4. B

    Suzuki DF 140 problem

    I have a DF 140 4 stroke 2004 that has the same problem the last 5 or 6 times out. Throttle up to 4K and it cuts out. Have tryed the usual, plugs, filter and new gas. It will run at 4 or 5K then drop to 2 or 3K for a moment then back up then back down just like a fuel block. The whole time...
  5. B

    Suzuki 225DT hard start

    Have a pair of 03 Suzuki 225DT and today noticed that the port engine was hard to start. Even after running a short time I would have to push the key to choke before it would start. Ran fine at all RPM's. Where would be a good place to start looking?
  6. B

    Suzuki DT225 idle

    Have a 03 DT225 that I would like to bump up the idle a bit. It's at about 500 rpm and sometimes will stall going into reverse. Looks like there is a nut with a screw in it on the throttle body that would do it but don't want to start without knowing for sure. Thanks
  7. B

    Installing steering cable

    Would like to know the correct way to install a cable in a new teleflex helm. After putting in there is a click about every two turns of the wheel, but not every time? Should the cable be disconnected from the engine before feeding the cable into the helm? Cable is good, no missing or damaged...
  8. B

    Suzuki DF140 dies out

    I have a 03 DF140. When I get up on plane about 4K it runs maybe 10 seconds then dies and then kicks back up without touching the trottle, runs another 10 sec. and dies down again. I'm thinking fuel and may start with the fuel-water filter and work back. No alarms or lights on the gauge. Is...
  9. B

    Suzuki oil tank

    Want to remove the oil tank on a 225 Suzuki 2-stroke. Have taken the 4 bolts out that hold it on but seems like something else is holding it in.Have any ideas?
  10. B

    Suzuki monitor gauge

    Is there a wire on the Suzuki monitor gauge that can be tapped into for a water temp gauge? It's a Suzuki 2003 225 2 stroke.
  11. B

    Suzuki water temp gauge

    Would like to hook up water temp gauge on a 225 Suzuki 2 stroke 2003. Had them on my old merc's and really liked them. Is there a way to hook into a wire on the Suzuki near the tach or key switch or go the long road to the engine? Would I be better off to get a teleflex kit and go from...
  12. B

    Suzuki water pressure gauge

    Would like to install a water pressure gauge on a 2003 Suzuki 225 2-stroke. Need to know where on the engine to hook up.
  13. B

    Suzuki conversion

    Have a 1996 Suzuki 115 fuel injected 2-stroke and want to repower with a 2004 Suzuki 140 4-stroke. Can you bolt up the new and use the old wire harness,controls,and tach or go with new? Also will the prop from the old fit the new shaft? Some say you can use all the old stuff and others say...
Top