Search results

  1. F

    Beware of this boat yard!!!! (my personal experience)

    EDIT: Sorry, cutter. We don't accept bashes. 4. Attacks (bashing) on any person, organization, company or other entity will not be permitted. 5. Reporting experience with any vendor, website or organization must be limited to facts. Unqualified attacks will be considered bashing.
  2. F

    oil spewing out of suzuki DF200

    My suzuki DF 200 (2005) shut down the other day while I was under way. I was cruising at about 4500 rpm when all of a sudden it sputtered, the oil light came on, then all of the lights and it shut down. We could see oil leeking out into the water, so we pulled off the cowling. Oil was all...
  3. F

    Suzuki DF 200 wont start

    As I prepared to tie up to the dock at the ramp the other day, my engine shut off and would not restart. I tryed all the troubleshooting tricks that I have learned during the 1700 plus hours that I have put on this engine. It will turn over and start for about a half a second then quit. I...
  4. F

    Water in gear case!

    While draining my gear case lube, I noticed a lot of water that came out of the gear case drain hole. I would say that about half of the fluid that came out was water and the other half was grey colored pasty water contaminated oil. Also, the water that came out was very clear looking. My...
  5. F

    yamaha F200

    My good friend has a yamaha F200 (2008) mounted on his 22 ft center console. At wide open throttle his rpms barely get up to 4900. That is with less than 3/4 fuel and two guys weighing around 210 lbs each. Shouldn't the rpms be higher??? I had him ask the dealer (who had installed the engine...
  6. F

    Suzuki df 200 fixed...not!

    Just got my boat back after having major engine problems caused by water contamination in the fuel. the high and low pressure fuel pumps and high and low pressure filters were replaced along with the fuel pressure regulator and the injector rails were cleaned. About 3 miles after launch the...
  7. F

    how could this be???

    I have a 2005 DF 200 Suzuki with almost 1000 hrs. A Couple of weeks ago the engine started running on 3 cylinders only (port bank) Today I got the call from my local Suzuki service center. I will need $1000.00 in parts alone. The parts include a new low pressure and a high pressure fuel pump...
  8. F

    running on 3 cylinders at idle

    My Suzuki DF200 just started running rough the other day at idle. We eventually found out that it was running on 3 cylinders. Anybody know what could cause this??
  9. F

    suzuki df 200 rough running

    I have a 2005 df 200 with almost 1000 hours. Until the other day it has run perfect without a hitch. Towards the end of our last trip though, it started running rough at idle and I noticed some smoke coming out of the exhaust. It should be noted that no warning horns sounded at any time...
  10. F

    Suzuki df200 thermostat

    Hey guys, I've found this forum to be very helpful in the last few months. So now that I am a new member, I have a question. My 2005 motor is 100 hours short of 1000 hours and it was recomended that I replace the thermostats. I have them but I am not sure what is involved to replace the old...
Top