Search results

  1. P

    Intermittent starting on 1996 Johnson 25 HP

    2 cylinder motor, starter and battery are confirmed good. And yes, starting I am pushing key in to activate the electric choke and I sometimes use the fast idle levee. It usually does not need it though
  2. P

    Intermittent starting on 1996 Johnson 25 HP

    I have a 25 hp Johnson from 1996 with some issues that I am struggling to diagnose. It has electric start, and is not a tiller (all is controlled from remote controls) It ran fine on another boat, and started right up immediately. I then swapped it to my pontoon early this spring. I fogged the...
  3. P

    Johnson 40e 74s blowing fuses

    Does anyone have a wiring diagram? I have been searching for days and for a similar one from evinrude and cannot find anything
  4. P

    Johnson 40e 74s blowing fuses

    I was able to diagnose that it is the blue coil wire with white stripe that was causing the problem. There is a dead short when even when the wiring harness for that coil wire is disconnected near the coil. Don’t know where to go from here. Here Is my current wiring layout on my key switch. Any...
  5. P

    Johnson 40e 74s blowing fuses

    So I had my motor running fine with no issue. It then blew the 20 amp short fuse. I replaced it, as well as the starter solenoid, but the issue did not stop. I purchased the motor from someone else who recently reinstalled coils and set points. Does anyone else have this issue? Or does anyone...
Top