Search results

  1. P

    Transom rebuild

    As I stated before I am rebuilding a 20ft Bass Buggy pontoon...The transom is still ok but I figure while I have this boat torn down I should go ahead and replace it. The existing transom is 1 1/2 inches thick. I have plenty of left over 3/4 in plywood from the deck boards..My question is....Do...
  2. P

    Air in tubes

    As I said earlier I am rebuilding a 20ft pontoon boat. I have the boat down to the bare essentials (tubes) and noticed a plug about 6ft from the front of each tube and another one about 6ft behind that one. I tried to loosen one of the small red plastic plugs and it came right out with only...
  3. P

    1989 Johnson

    I recently bought a used 40hp Johnson. Had it checked out professionally and the engine is good. However the tech noticed that the trim tab was missing. I talked to the guy I bought the motor from and he said it had been missing for years, with no adverse effect, that they were really not...
  4. P

    Pontoon Re-Build

    This is a first for me, but I am rebuilding a 20ft Bass Tracker pontoon, I am trying to get all the hardware etc together before I start the tear-down. The only problem I have found is the screws that hold the plywood to the frame. The screws that I am removing have a large head (dime size) with...
  5. P

    Pontoon to trailer straps

    I just purchased a used 20 ft Pontoon boat from my brother-in-law and he delivered it to me a few days ago ( a distance of over 200 miles), and I noticed it has no way of securing the pontoon boat to the trailer. Brother-in-law stated he had never seen a pontoon tied down. I am new to the...
  6. P

    To Paint or not to paint

    I have a 1987 Tracker Bass Buggy Pontoon and the deck needs replacing. I have purchased the marine plywood to replace the deck.....Several people have suggested that even though I bought Marine plywood it would still be a good idea to paint the wood prior to installation...Should I paint and if...
  7. P

    To Paint or Not to Paint

    I have a 1987 Tracker Bass Buggy and the floor has to be replaced. I have purchased the 3/4" marine plywood that I need for the job, My question stems from several comments from some non-knowledgeable friend who say that even tho I have marine plywood I should still paint the new plywood before...
  8. P

    turning hitch over

    Once again a possible dumb question..I just purchased a used 20ft pontoon boat and I noticed that the trailer has a "down hill" angle when it is hooked up to my truck that is not caused by the rear of the truck being over loaded. When the boat is hooked up the truck "squats" less than 2...
  9. P

    Dirty Pontoons

    I recently purchased a used pontoon boat from my brother-in-law. The only problem I have with the boat is the pontoons. My brother-in-law lives on a hugh lake and the boat has been in the water for 2 or 3 years. The boat itself looks great but the pontoons really tear down on the apperance of...
  10. P

    second-hand boat

    My brother in law has a 20 ft 1978 or 1979 Bass Buggy Aluminum pontoon boat. He says it is a good boat except that the front deck needs replaced. It has a 40 hp Johnson motor that runs good and the upholstry and deck carpet is in good shape. He is being transferred and wants to sell the boat...
  11. P

    Batteries

    I have a deep cycle battery that I use for my trolling motor, however I live in the great but very dry state of Georgia. We have experienced an extreme drought this summer and all the small lakes have dried up and some of the larger ones are on their way. Therefore I am looking at it being...
  12. P

    Old? trolling motor

    I recently purchased an old (?) PFLUEGER PHANTOM trolling motor at an estate sale. It is an M.2 serial number 106002.......Does anyone have any info concerning this unit. The top is almost round but slightly oblong...a single toggle switch for high/off/low and the instruction to run only when...
  13. P

    Is this motor legit

    I have a Ted Williams 7.5 hp outboard Model 217.585880 s/n 6D 061379. I have been told that this is an engine built by Eska, however when I removed the engine cover a few days ago to repaint I found a tag on the engine with the following: 640-13 Tecumseh 7819566 Is this an outboard motor that...
  14. P

    Fuel shut off valve

    I need a fuel shut off valve for my 1975 ted Williams 7.5 hp Model 217/585880 s/n 6D061379....Mine still works but you have to use small pliers to completely cut the fuel off because the t-handle is broken off. Sears no longer carries this part. Thanks
  15. P

    Dumb question

    I am very new to this, but here is my question...I recently purchased a 14 ft jon boat at an estate auction for almost nothing. It is just a simple aluminum boat.The transom on the inside of the boat was rotted out which I repaired, however on the outside of the hull there was an additional...
  16. P

    Replacing impeller

    Can anyone offer any type of instructions etc as to the proper way to install a new impeller for my 1975 Ted Williams motor Model# 217/585880 S/N 6D061379. The engine runs great and I hate to mess up by getting in over my head and ruining a good little engine. I have a diagram and parts list I...
  17. P

    Replacing Impeller Sears p/n 26251

    I have ordered the above part and will attemt installation when it arrives..This engine ,217/585880, runs great even after being in storage for over 15 years, but I figured the impeller need to be replaced due to dry rot. what type of gear lube should I use in the gear housing after the...
  18. P

    Air Filter

    I have a Ted Williams 7.5 outboard Model217/585880. being new to this my question may seem dumb but do these engines not have air filters? My engines seems to be totally without an airfilter nor any place to put one. Most of the small engines I have worked on it the past have all had filters...
  19. P

    repair/operator manual

    I have a 1975 Ted Williams 7.5hp model# 217/585880 s/n# 6D061379. Does anyone know where I can get manuals for this unit, thanks
  20. P

    What year is my outboard

    I recently acquired a Ted Williams 7.5 hp motor, and would like some info regarding the year and possibly operating/repair manuals...It is a model 217/585888-0 s/n 6D 061379. If you have any info as to where I can aquire the manuals, I would really appreciate it. Thanks
Top