Search results

  1. R

    Johnson 150 Starts Out of Water but Not In Water

    Brush kits from local starter / alternator shop were $5.00 for me.
  2. R

    90hp lower unit to 120

    May have to check driveshaft length.----Will have to change shift rod.----Shift rod need to be set at the correct height.
  3. R

    Johnson 150 Starts Out of Water but Not In Water

    There you go , get a factory starter.---Have battery load tested.
  4. R

    Johnson 150 Starts Out of Water but Not In Water

    Maybe exhaust relief is blocked / plugged.----Or crankcase compression is low and unable to overcome water pressure.
  5. R

    Stator 6hp non standard

    Add packing washers and tighten the nut.
  6. R

    three plugs in lower unit

    Always fill from the bottom !!-----------------
  7. R

    Eska 1945b compression test

    There are better motors out there.-----That one should be a free parts motor.
  8. R

    johnson 115 no spark on right side of motor

    I don't think there is a shift interrupt switch on that motor!
  9. R

    1984 force 125 fuel pump question?

    Inferior materials sold online.-----A common problem.----Visit your local Mercury dealer and install good stuff.
  10. R

    1984 force 125 fuel pump question?

    I would repair these simple pumps.-----Did you order a new pump online.----Made offshore perhaps ?
  11. R

    Johnson 10hp driveshaft

    There should be an o-ring that goes into the groove just below the spline.----Very important to keep water out of the joint.
  12. R

    johnson 115 no spark on right side of motor

    Model # of the motor ?
  13. R

    Johnson 150 Starts Out of Water but Not In Water

    You are pushing key in and holding it in while cranking it over?------Step #1 is to post compression test results for this issue.-----Sounds like low compression in the CRANKCASE might be a issue.
  14. R

    Johnson 10hp driveshaft

    There should be a spline at the top of the driveshaft.----Slides into the spline in the crankshaft.------Post pictures here.
  15. R

    Stator 6hp non standard

    Most OMC parts have a 6 digit casting number on them !!
  16. R

    Stator 6hp non standard

    Is the brass insert loose in the aluminum plate ?----This would not be my approach to this repair.----Is there a 6 digit number on that aluminum plate ?
  17. R

    1976 Johnson outboard 9.9HP 10R76H diagnosis

    Step #1 is a compression test.----No point throwing beer tokens ($$$ ) at a worn out motor.----Does spark jump a gap of 1/4" or more.----Check the flywheel key.----A sheared key means no spark condition.-----Test driver coil.----Clean breaker points and recheck for spark.
  18. R

    Gear oil for mercury 60hp

    Gears still cost big beer tokens for old motors.----Good factory oil is cheap considering.
  19. R

    Outboard not running right with cowling on... and a fix!

    Many manuals say ---" do not run full throttle with air box off "---With all those holes the air box cover does nothing.
  20. R

    Outboard not running right with cowling on... and a fix!

    You should fix what is wrong !!
Top