Search results

  1. legalfee

    Prop ?

    What Jim says. Verify that you don't have water in your pontoons and your motor is running right. Then verify with a good tach what your RPMs at WOT is. Then find out your MPH using GPS. Once you find this out then you can go about finding the right pitch for your prop. The numbers on your prop...
  2. legalfee

    Aftermarket stator wiring Force 120

    CDI Stator
  3. legalfee

    Aftermarket stator wiring Force 120

    Serial number should be on the transom bracket. The CMI part number is 174-2075K 2 and looks like your picture. The CMI is 16 amps.
  4. legalfee

    Boat Radio/Stereo Help

    I use a motorcycle battery for my radio. Works great and when it dies I recharge it.
  5. legalfee

    Gear case cover

    Yeah there's a type A and B-C-D.
  6. legalfee

    Gear case cover

    Can you point out the part you need?
  7. legalfee

    Pontoon gas tanks

    I would suggest a 20 gallon tank with the fuel gauge sender included: https://www.ebay.com/itm/Moeller-Boat-Fuel-Tank-FT2045-20-Gallon-33-x-16-1-2-Inch-Poly/402773819929?hash=item5dc730c219:g:rlkAAOSwL0hgZc5O
  8. legalfee

    Replace kill switch or bypass?

    I would suggest following these troubleshooting steps rather than throwing parts at the problem: NO FIRE ON ANY CYLINDER: 1. Disconnect the Black/Yellow kill wire AT THE SWITCHBOX and retest. If the engine’s Ignition now has spark, the stop circuit has a fault. Check the key switch, harness...
  9. legalfee

    94' Suntracker pontoon 30' controls question

    Electronic Engineer. I'm self taught on these 2 stroke motors but I've learned a ton from Jerry and others on this site.
  10. legalfee

    94' Suntracker pontoon 30' controls question

    From CDI: NO FIRE ON ANY CYLINDER: 1. Disconnect the Black/Yellow kill wire AT THE SWITCHBOX and retest. If the engine’s Ignition now has spark, the stop circuit has a fault. Check the key switch, harness, and shift switch (if present). 2. Disconnect the Yellow wires from the Stator to the...
  11. legalfee

    94' Suntracker pontoon 30' controls question

    The wire is on the switchbox on the motor:
  12. legalfee

    Repairing Plexiglass Windshield

    Not yet. They said I should get it around April 15th. Also they said they would not drill the four holes but would include a bit. That makes me nervous that it might crack.
  13. legalfee

    94' Suntracker pontoon 30' controls question

    I would post your question to the Force forum. The kill switch is easy to bypass just unplug the yellow / black wire. https://forums.iboats.com/forum/force-chrysler-outboards.29/
  14. legalfee

    40hp force outboard owners. year? And wire question.

    This^^^ Google this part number for the 92-94 impeller: 47-f433065-2
  15. legalfee

    Buying a ‘toon advice

    We bought a 24ft 1995 Sylvan with a 90hp 2 stroke for 4K. The seats and carpet were not in good condition but we used it for a few years and replaced the seats and helm and had a vinyl floor put in for 6K. I have done most of the work on the motor and the next upgrade will be to a 4 stroke...
  16. legalfee

    Startup procedure

    On my 1995 90hp the above procedures. If it doesn't crank by the third or fourth try then this: Throttle to wide open, remove cowl, spray starting fluid into the three carbs. Start motor.
  17. legalfee

    What are the essential tools to keep on board?

  18. legalfee

    Suggestions for replacement floor covering

    This is what I got: Doesn't slip, doesn't get hot, easy to clean.
  19. legalfee

    221 Donzi

  20. legalfee

    Bimini replacement top; can't find same size as current one.

    You could just buy a 8 x 8 with the frame: https://www.pontoonstuff.com/collections/pontoon-boat-bimini-tops/products/heavy-duty-pontoon-bimini-tops
Top