Search results

  1. B

    Pink Super Tech (Walmart) -50 RV and Marine ok for engine?? I always thought NO...??

    I`ve used it for several years and have had no problems so far. I live in central Indiana so it can get pretty cold at times.
  2. B

    Do you have a DIY vacuum / pressure tester?

    Check ebay. I bought my pressure and vacuum tester there. Used but still functional and much cheaper than buying new.
  3. B

    Volvo DP-SM water in oil

    I found my pressure and vacuum testers on ebay used, but they still work well and were significantly cheaper than buying new.
  4. B

    Volvo DP-SM water in oil

    Possibly a propeller shaft seal going bad. You need to pressure and vacuum test on the unit to see exactly where the leak is coming from.
  5. B

    Question about paint chips in fuel system

    Prop pitch can play into engine not getting to full RPM`s. Might consider looking there before tearing into engine.
  6. B

    Water pump leak?

    It`s not advisable to run the engine with the drive in the up position. Very hard on the U joints.
  7. B

    Crack on drive unit - how concerned should I be?

    When you can pressure test the casing to see if there is an air leak from that area or any seals. If not, you should be ok. Just be ginger when tightening that nut.
  8. B

    Oil selection

    I`ve used Rotella T6 and Mobil 1. I would try to run full synthetic given a choice but I would not get hung up on "marine " specific oils.
  9. B

    Does my GL-5 75W90 need to be official?

    I`ve been told that Mobil 1 has limited slip additives. I believe VP suggests non limited slip additives because of the cone clutch. I run Amsoil gear oil as it has water absorbing abilities.
  10. B

    Alignment adjustment, witness marks

    The front of the engine needs to come up a bit.
  11. B

    2006 volvo penta 5.7 rebuild help

    When I replaced my 5.7 gxi, I went with a new Michigan Motorz long block. I transferred over my intake and exhaust, PS pump, alternator and water pump. I have ran it now for about six years and could not be happier. Might give their website a look.
  12. B

    SX-A thread repair

    Try coating the threads with a liberal amount of Tripple Guard grease. It may just give you the seal you need.
  13. B

    SX-A Gear Oil Screw

    Impact driver with a drag link socket bit on it.
  14. B

    VP 2007 3L 135HP engine oil options

    Your gear oil need to NOT to have limited slip additives. Many automotive gear oils do, you need to find one that does not. I use Amsoil marine gear oil.
  15. B

    Starting boat after 4 years - pre start steps

    In addition to what you have mentioned, I would prime the oiling system by cranking the motor by over for a bit with the ignition(spark) killed to get some new oil into the passages and on the bearings.
  16. B

    Aftermarket fuel pump recommendations

    I bought a back up pump off of Amazon and used it while I rebuilt my OEM. I can't remember what brand it was but it worked fine while I used it. Look for a brand that has the best reviews I`d say.
  17. B

    VP SX drive low oil but no sign of leak

    Always fill until it flows from the upper side vent screw hole. It is possible that you could have a driveshaft seal bad and that the oil has gone into the bellows. Now that you have the oil level registering on the dipstick, run it for a while and check it again to see if it has fallen. If not...
  18. B

    5.0 GXi fuel problem

    If the pump is sucking your gas from the separator/filter and running for a brief time then it may not be the pump itself but in the fuel delivery system to the pump. Try running the boat on a separate gas supply from the boat tank and see if it will run longer. Basically hook the pump inlet up...
  19. B

    Volvo Penta Trim Cylinder issue

    Sounds like a clogged line. Might try to clear by removing and blowing air through it.
  20. B

    Rusty engine pulleys

    Sand it down and re-paint
Top