Search results

  1. I

    tune up trouble

    I have a 1967 Chrysler Courier with a 120 hp mercruiser. I was doing a tune up and when I checked the timing, the mark was an inch away from the little tab that shows where to adjust to, also the tab dose not have multiple marks. It is just a thin metal tab with a line "scraped" into the paint...
  2. I

    mercruiser 120 shifting problem

    I have a 1967 Chrysler courier with a 120hp mercruiser engine. I have been having problems getting the boat out of gear. someone told me about something called a shift interrupter switch. I adjusted the linkage to properly actuate the switch and it worked great for a couple of times out on the...
  3. I

    shifting problem??/

    I have a 1967 120 hp mercruiser #2055736 with a alpha one sterndrive #2072395. Last week I was fishing on the delta and ran through some weeds that did not clear the prob so I stoped, put it into reverse and gunned it to clear the prop. after doing this the boat would not go back into forward...
  4. I

    mercruiser shifting problems

    I have a 1967 120 hp mercruiser #2055736 with a sterndrive #2072395. It will not shift into forward gear. I adjusted the shift cables from one side all the way to the other in small increments but one way gets me no shifting at all while the other way gets me stuck in revers. I was told it is...
  5. I

    MerCruiser shifting problem???

    I have a 120 HP 4 cylinder mercruiser serial #2055736. Im not sure what model the outdrive is but the serial # on it is 2072395. This is on a 1967 Chrysler Courier 229. I bought it a couple of months back and it has trouble shifting. When going into forward you have to push the throttle handle...
  6. I

    Fuel mix and spark plug gap??? 15 hp 89' Johnson

    I have a 1989 johnson 15 hp electric start outboard, model # J15ELCEC. I was wondering what the fuel to oil ratio was for this year of outboard. I have been running it at a 32:1 mix. I was also wondering what the spark plug gap is supposed to be?
  7. I

    convertion to throttle body fuel injection

    I have a 86 Searay 23 that has a lot of carburator problems it has a quadrajet carb. It has been replaced a few times over the years but usually does not take long to act up. It floods, and is often hard to start. I am consitering salvaging the throttle body fuel injection and all related parts...
  8. I

    torque specs for flywheel? 15hp

    I have a 15 hp johnson electric start J15ELCEC. I broke a woodruff key and the flywheel jammed on the power pack, bending the min. idle screw bracket. I bent everything back and replaced the key and tryed running it again. This time the woodruff key was fine and the fly wheel was tight but it...
  9. I

    1989 Johnson 15...Flywheel trouble

    I have a 1989 15 hp johnson electric start outboard. MOD # J15ELCEC I sheared off half of the woodruff Key for the flywheel. When this happened the flywheel jammed on the power pack and the charge coil for the ignition plate, causing the bracket that holds the min. idle screw to bend all out of...
Top