Search results

  1. S

    96 Evinrude 20 no charge

    Ok so you cannot trust a new rectifier even if it checks good on a meter. I replaced again and it's working. Thank you everyone.
  2. S

    96 Evinrude 20 no charge

    Done that. I've been doing that for a long time. Every trip out I recharge the batteries. It's a deep cycle marine battery.
  3. S

    96 Evinrude 20 no charge

    I never see charge voltage out of the rectifier. Running I never see a voltage higher than the battery voltage unless I'm at almost full throttle. I have rechecked charging coils, rectifier, wires and they all check out with a meter. I get ac out of the coils about 15 vac but it Needs at...
  4. S

    96 Evinrude 20 no charge

  5. S

    96 Evinrude 20 no charge

    E20eleda is model number
  6. S

    96 Evinrude 20 no charge

    E20eleda is model number
  7. S

    96 Evinrude 20 no charge

    Yes I just did not run it up high enough.When I run it up I get low teens. With new regulator I also get some charging voltage but not the 14+ that is expected. Battery at rest engine off supplies 12.7 I am able to get 12.9 at 2/3 throttle guessing 2500 rpm.
  8. S

    96 Evinrude 20 no charge

    I'm about ready lol
  9. S

    96 Evinrude 20 no charge

    I have 4.5-5 volts ac the rectifier is bolted to the frame (ground) of the motor. Good ideas I'll get another cheap rectifier just to eliminate it one more time . Thank you I don't think so. It's not in the wiring diagram but I'll look closer. Thank you
  10. S

    96 Evinrude 20 no charge

    Charging coils and what I think they call ignition coil were bad. Broken wire on charging coils and ignition coil was melted. I replaced those and the rectifier as that was testing bad as well. With everything connected it still not charging the battery. Voltage exactly the same running or off...
  11. S

    96 evinrude 20 hp runs rough mid range

    Compression 100 both cylinders cold 105 warm. most of the work on the carb was 4 years ago. There was no change after except I fixed the worst problem which was vaporlocking when warm. Was probably fuel line as it resolved after addressing connections.That is not an issue anymore but everything...
  12. S

    96 evinrude 20 hp runs rough mid range

    This is an ongoing problem. Since I either troll or run it on a plane (80-85% throttle it's livable but vexing. At idle and a short amount above that it runs smooth. When I open it up anything less than say 75% I seem to lose one cylinder. I have rebuilt the carb,changed the leaf valve, replaced...
  13. S

    Did I get a bad regulator?

    racerone thank you for your help. I checked again with a better meter no change. Last time I got involved with this motor on a fuel issue I spent way too much time figuring things out after the dealers locally turned up their nose at the work. I'll start looking for someone to do it.
  14. S

    Did I get a bad regulator?

    What should I have gotten?
  15. S

    Did I get a bad regulator?

    I have one ohm on one set and 40 on the other.
  16. S

    Did I get a bad regulator?

    Evinrude 1996 20 when running does not charge battery. Voltage at battery never goes above static battery voltage. Checked regulator with meter and it's open in all directions. Picked up a replacement at the dealer and today I checked it before installing and I get the same readings, everything...
  17. S

    grinding when shifting in to reverse 25 hp merc EFI

    Runs well, when I put in to forward smooth entry and works as it should, when I put into reverse even from stop, a get a grind (slow but there) when I try to put in reverse after that it works as it should. No other issues. Is this an issue I need to worry about?
  18. S

    25 merc 4 stroke 2007 wont start with electric starter

    thank you I'll start with the wires and connections.
  19. S

    25 merc 4 stroke 2007 wont start with electric starter

    This motor starts first or second pull. Runs well when started. Power tilt works at all times. When I try to start it using the electric starter, there is a click, sometimes a small whine (1/2 second long) and the console lights dim. Battery replaced and no help. this started and at first was...
  20. S

    charging /electrical output for 20 hp evinrude 1996 two stroke

    I want to add some motorized equipment to my little boat. I am concerned that it will overload the charging system, I currently run a fish finder and two down riggers (which are coming off.) The units I want to add are motorized jig boxes that I am building and will use either 6 amps at 12 vdc...
Top