Search results

  1. 04fxdwgi25

    No compression with rocker arms torqued

    It is great when that "tada" moment hits, isn't it. Non adjustable valve train should not be in these engines. A changed head gasket can throw them off. Just a way for the factory to save $3.00 in assembly labor.
  2. 04fxdwgi25

    Hopkins 4 pin tester

    1st question, what kind of truck is it? Each type of truck has it's own quirks, so need to know that. It sounds like your truck is the problem. Can be multiple fuses going to that connector plus, the 12V outputs to the connector could be controlled by the Body Control Module (BCM) There is...
  3. 04fxdwgi25

    Trim Tilt 3 toggle control wiring.

    Need to hit the middle and top buttons at same time. That bypasses the up limit so the drive can go all the way up to the trailer position (Do not run engine when drive is up there. Will cause damage). The top button is the trailer (limit bypass) button
  4. 04fxdwgi25

    Wiring Problem on Tilt trailer

    If the running lights don't work, you have a problem with the wiring / plug on the brown wire. Just follow the diagram I supplied and start probing to see where the problem is. Not unheard of for a wire to rot off inside the insulation.
  5. 04fxdwgi25

    Wiring Problem on Tilt trailer

    Is there a "bonding wire" connecting the stationary section of frame to the tilting section? That pivot point is a poor bond.
  6. 04fxdwgi25

    Wiring Problem on Tilt trailer

    Have you checked the wiring on the vehicle pulling it? May be a crap ground on that end. Do not expect the trailer ball to be the ground. Bad decision if someone does. The white wire ground should be good on vehicle and trailer.
  7. 04fxdwgi25

    Flushing Device

    If you are talking about the "muffs" type, they will always squirt excess water out around them.
  8. 04fxdwgi25

    2000 Mercruiser 5.0 Thunderbolt 5 Ignition idle issue.

    That sounds like a fuel delivery situation. If engine is a carbed engine, then maybe low fuel pressure to the carb or a bad float adjustment? Or perhaps the engine is running too rich and dying. Is the choke opening up as it should when warming up? Kind of difficult to diagnose with the limited...
  9. 04fxdwgi25

    Different risers and elbows

    Google is your friend. Just type in: "mercruiser s/s riser plate"
  10. 04fxdwgi25

    Single point drain leaks. Serious? Eliminate it?

    Hardin Marine makes S/S ones and a pack of 5 is cheaper than 5 OEM blue plastic ones from the dealer.
  11. 04fxdwgi25

    Official Recall Notification U.S. Federal Boat Safety Act:

    Yes, that 802893T is the spin on for my boat. Never seen one with an "O" ring, always have the square seal on them. Can't find the recall on the net anywhere.
  12. 04fxdwgi25

    Trailer bearing frustration

    Glad you got it all worked out. Anyone that says everything is always perfect speak with forked tongue.
  13. 04fxdwgi25

    Trailer bearing frustration

    Are the spindles attached to a fixed axle or are they torsion axles? Has to be a bearing / bearing race mismatch or the wrong hub, or both.. Compare everything to the other one that is correct. That should solve the problem, or at least give an indication of where the problem lies. Only fly...
  14. 04fxdwgi25

    How can I troubleshoot the wrong trailer light

    Or an open / bad ground on one of the lights on the trailer. If one light isn't grounded properly, it usually looks for a ground through any common wiring such as the running / tail lights. Look for a bad ground on the left tail light.
  15. 04fxdwgi25

    7.4 Bravo water pump driven fuel pump

    Actually, those raw water pump drives with the fuel pump are pretty easy to rebuild (bearings and seals) and parts are readily available. That ring flopping around is normal. The mechanical fuel pump # are: (believe the OEM is made by Airtex) OEM part # - 861677T Carter # - M60932 Sierra # -...
  16. 04fxdwgi25

    rocker switches

    Right here on this site: https://www.iboats.com/shop/electrical/marine-switches-battery-ignition-rocker-and-toggle-switches.html Or for a huge selection of switches of various configurations: https://newwiremarine.com/marine-grade-switches/
  17. 04fxdwgi25

    Steering tight/hard to turn when i turn right

    One place that won't show up easily is the power steering cooler. That would be a pressure test in the cooler inlet and outlet lines. The leaked oil goes right out through the exhaust with the cooling water. Good luck....
  18. 04fxdwgi25

    Missing bolt behind motor

    I would say he is pretty lucky the boat hasn't sunk yet. But should have noticed excess water in the bilge. Can see where it has been leaking a considerable amount of water. Also, with air leak there, the Bravo raw water pump may have a tough time pulling a good suction, causing cooling...
  19. 04fxdwgi25

    When my boat is on the trailer, this happens.

    Perhaps English isn't 1st language...... Kind of a "rough" comment.
  20. 04fxdwgi25

    Illinois registration numbers?

    Only time no numbers are needed are the "documented boats" that registered thru the CG. But they have their own set of number display rules.
Top