Search results

  1. Fun Times

    Mercury 6.2 ECT DTS Axius Voltage Issue

    At the moment I may have yours confused with alldodge...Were the batteries just ordered and installed new?...Plus wasn't recently an issue found with the battery switch and a new one put in? Or was that AD? The thicker wiring color coming of the back of the alternator, is it Orange or Red? Or...
  2. Fun Times

    Quicksilver gimbal bearing dot alignment

    While my personal preference is to follow the book as much as possible as long as I believe it’s correct and I’m this case I do tend to personally ensure the bearing ends up in the 10 o’clock possession but in recent years past here on the forums, the bearing has been fully measured out and they...
  3. Fun Times

    Trim Control Rubber Boot?

    Possibly either the trim handle button is sticking, or I've seen a few where the trim system wiring at/behind the shift control unit 'white wiring "plastic plug connector" was laying on the bottom submerged in water at times and had corroded out enough that the down wire was getting power in...
  4. Fun Times

    Trim Control Rubber Boot?

    Do you know if it is going down electrically powering up the pump or hydraulically such as maybe a leak someplace?
  5. Fun Times

    Look what I found in Maine

    How awesome you two were able to meet up like that.:cool:(y):)
  6. Fun Times

    Fresh Mercruiser swap. No power

    See post number 9 again for a bit of humor / worst case scenario. :) Always carry a test light in the car as it's an easier way to check fuses, etc. on the quick. :)
  7. Fun Times

    Fresh Mercruiser swap. No power

    Anyone near you at the moment that might have a test light to borrow? :D How to make your own test light / circuit tester. DIY incandescent test light.
  8. Fun Times

    06' 5.0 MPI intermittent fuel issue

    Sounds like you may want to start off testing what the fuel pressure is by either buying or maybe renting a fuel pressure tester kit from an auto parts store. An Actron fuel pressure tester kit should help you out that fits your schrader valve size...
  9. Fun Times

    Fresh Mercruiser swap. No power

    Should be the 50 amp mercruiser circuit breaker, Does yours have the 90 amp fuse at the starter?
  10. Fun Times

    Fresh Mercruiser swap. No power

    Test light handy by chance or local store? Mercruiser uses a starter slave solenoid to help activate the starter solenoid.
  11. Fun Times

    Fresh Mercruiser swap. No power

    Is there power at the breaker 2 red wires? Is there 12v power from the battery to the engine starter? Main wire at the alternator has 12 volt power? Wiggle the main engine wiring harness. Some 3.0's have while some 3.0's don't have a 90 amp fuse at the engine starter.
  12. Fun Times

    Starter for V8-300-C-A

    You might be fighting some paint from the manufacturer as well as the bolt torque too. Is the area clean down there? How is the access to the starter bolts and wiring on your boat model? Are you able to take a few photos to help see what it looks like down there? as sometimes a visual may help...
  13. Fun Times

    What is this thing?

    Isn't there an open hole / with screen on the side we can't see in the photo? I'd say possible a drain for the front anchor lid,
  14. Fun Times

    4.3 Main Breaker Cover

    Mercury-Mercruiser 85-96819T INSULATOR, CIRCUIT BREAKER Item number 31, https://www.mercruiserparts.com/bam/subassembly/31466/951/70 This product is not being produced anymore however may still be available through other dealers. Name City State CONTINENTAL MARINA BUZZARDS BAY MA Website...
  15. Fun Times

    2015 4.5 no start/trim

    Start with page 38 - 41, https://mnappsp.mercurymarine.com/mmliterature/pages/viewpdf.jsp?pdfpath=SERVICE%2FCRUISER%2FOWNER%2F15%2F8M0103371.PDF&name=4.5L A 15‑amp fuse located at the aft end of the engine, protects the accessory circuits. This power package uses a clean power harness that is...
  16. Fun Times

    2015 4.5 no start/trim

    The click may another blow fuse and probably blowing 2 of them (or more)… one trim and the other ignition power…. Plus you should have relays involved in your system. Have you located all the fuses on the engine yet and checked them to see if they look blown? With fuses blowing, something is...
  17. Fun Times

    Overheating 502

    Yes that is a check valve to help keep hot water from getting to the fuel cooler pump system… Merc part number 21-862271A1. It could be an issue… but I just now saw where you mentioned you had bell housing type service work done… I would first thoroughly double check the intake waterline hose...
  18. Fun Times

    Stupid rookie mistake...

    You’re good.👍
  19. Fun Times

    No beep, no buzz, no start. 2004 Mercruiser 350 Mag

    Thinking possibly a fuse or relay located on the engine is having issues. Could try lightly tapping on the relays while the key is on to see if it helps jog it loose that and/or swap them out to see if things change symptoms...also try wiggling the main wiring harness on the engine. Do the...
  20. Fun Times

    5.0 MPI Water Pressure Sensor

    These water psi sensors are sometimes problematic at times. Though it should go to 0 psi with the engine off, key on. You could first try removing it, inspecting and cleaning and even testing it's ohms value to see if helps any. Being it's staying in range, it shouldn't create any fault codes...
Top