Search results

  1. Bt Doctur

    Trying to find a transom seal kit. Alpha 1 Gen 2, I think

    Look at Quicksilver QSL 803099T1 includes the gimbal bearing or Sierra SIE1882061 w/ standard bearing or SIE 188218 w/ permalube gimbal bearing
  2. Bt Doctur

    Starter wont engage flywheel.

    Easiest way is by the firing order. Wondering if its a V drive configuration?
  3. Bt Doctur

    Mercruiser Shift Issues

    Being a GEN II that shiftshaft should be butter easy to rotate
  4. Bt Doctur

    Need help with Rotary Steering Cable!

    If you removed the cable and its free, then look elseware. Remove the SS pin in the steering arm. Try to straighten the cotter pin first, if not grab the eye of the pin with dikes and pull it out, then remove the pin. The drive should move side to side . meaning the PS actuator is seized. If the...
  5. Bt Doctur

    Starter wont engage flywheel.

    With a counter rotation motor you use just the opposite ,With rear entry starters For a reverse rotation motor you use standard starter and for a standard rotation motor you use a reverse rotation starter
  6. Bt Doctur

    Starter wont engage flywheel.

    What direction is the crank pully turning? Locate #1 plug wire in the dist cap, Is the next wire going clockwise going to cyl 2 or cyl 8 ? If an I/O you use a standard or reverse rotation starters Mercruiser 50-808011A05 Inboard Starter Rear Entry LH-Rotation Engines. Replaces older Mercruiser...
  7. Bt Doctur

    3,0l tks carb flooding

    usually caused by a leaky needle and seat
  8. Bt Doctur

    Outdrive Wont Go Up

    there are 2 hoses with that pump system. There are two hoses going to the bottom of the ram on each side of the Clarify: 2 hoses to each cylinder or 2 hoses with 1 going to each cylinder
  9. Bt Doctur

    PDF Service manual for 4.5L

    Havent seen a scanned copy anywhere yet,but I keep looking
  10. Bt Doctur

    Alpha knocking noise video.

    u joints or a destroyed gimbal gearing. When was the drive removed for service last?
  11. Bt Doctur

    Removing Shift Assist

    I would install a spacer on the pin so that it doesent get caught Removing it also prevents premature control cable failure
  12. Bt Doctur

    Coupler

    But is more likely you have an alignment issue
  13. Bt Doctur

    What rotation out drive to buy

    All I/O engines are standard rotation left hand when seen from the flywheel To clear up Bondo, the prop turns to the right not the engine The gear ratio should be 1.84-1
  14. Bt Doctur

    MerCruiser single point drain leak.

  15. Bt Doctur

    Alpha 1 Gen 1 - Teardown - Need Advice

    If the pump base is melted even slightly you have overheated and the base needs replacing
  16. Bt Doctur

    Bravo 3 steering pin question

    be a good idea to drill in a grease fitting too
  17. Bt Doctur

    First Start of the year and High Oil Pressure

    sender is for a gauge, sensor for alarm circuit
  18. Bt Doctur

    Can you use car oil in a Mercruiser 3.0 engine

    25w-40, 20w-50 straight 30 but not 10-40
  19. Bt Doctur

    2011 Mercruiser 4.3L TKS high temp @ low rpm

    verify the water inlet hose at the transom does not have a kink
  20. Bt Doctur

    Mercruiser 305 V8 running hot at low RPM fine at Speed

    When was the impeller replaced?
View older results
Top