Search results

  1. Faztbullet

    Copper crush washers ok to use?

    Use the Merc yellow washers as they are reusable,dont deform and I use them on all my customers with no leaks.
  2. Faztbullet

    Diode installation on 1972 Rude CD Ignition

    Can you get a spark to jump a gap from the coil only? If not you got problem with CD output. The OMC start upgrade was to run a wire from the white wire (key switch) from solenoid to 12v ignition wire from key on CD unit. The diode is placed inline on the jumper wire to prevent feed back to...
  3. Faztbullet

    Engine building tip regarding gel-seal?

    Build all my V4/6 loopers this way :)
  4. Faztbullet

    Mercury Tilt and Trim units

    So you just need a body and trim rods?
  5. Faztbullet

    Prepping heads/block for new gasket

    Short piece of 2x4 and 220 grit makes a good sanding block for this.
  6. Faztbullet

    1993 Johnson, 200 hp help!

    One wire to grnd in remote, other two to the M terminals
  7. Faztbullet

    Leaking water behind fuel pump

    Fuel cooler hose clamp is leaking or was cracked during repair
  8. Faztbullet

    CDI High Speed Failure

    Be careful on the cheap boxes from Amazon as they can damage your motor. Only use the OEM, Serria or Prufex
  9. Faztbullet

    100293R Evinrude Starflite will NOT START, pulling hair out need expert help!

    I went thru 4 of these units bad out of box before getting a good one.
  10. Faztbullet

    100293R Evinrude Starflite will NOT START, pulling hair out need expert help!

    Put the old pack back on
  11. Faztbullet

    1988 Johnson 90 hp V4 carb has no suction top carb

    A dead cylinder will cause this also
  12. Faztbullet

    2002 225 Optimax - Overheating at idle only

    Check the strainer in the exhaust plate also
  13. Faztbullet

    50hp mercury leaking water above the cavitation playe

    Leak is normal...carbs sound like one is lean. Check under cowl for dirt dabber nest in air intakes
  14. Faztbullet

    2001 Mercury 90 Hp 3 cylinder outboard

    Kill tether yanked?
  15. Faztbullet

    2004 115 HP EFI Mercury Pushing Fuel Out the Exhaust

    Compression test needed and stop using it.
  16. Faztbullet

    Mariner 45hp Carburetor Leaking after Total Rebuild....stumped!

    Only use Mercury needles
  17. Faztbullet

    1994 mercury 25hp 2 stroke

    Be careful as that's a Mercosil engine block. Have to use special type tools to repair cylinders if damaged
  18. Faztbullet

    CDI High Speed Failure

    Doubt stator will fix it...
  19. Faztbullet

    1976 Mercury 500 only runs for a few seconds

    Sound like carbs and fuel pump diaphragms needs to be addressed again. If installed incorrectly or wrong type the lil flapper ears do not seal the passages in carb body.
  20. Faztbullet

    How do I test a shift interrupter switch?

    Clean points and check points wire to see if constant grounded
Top