Search results

  1. C

    1994 mercury mercruiser engine not starting

    Possibly, but ether explodes under compression as well as any kind of spark. Keep a fire extinguisher handy when using ether. Testing the spark to all cylinders, especially with a timing light is the best way. Remember, on your 4 cycle motor, spark needs to occur on the compression stroke...
  2. C

    Upsizing fuel connector on 83 johnson

    If you have a built in fuel tank, why not just direct connect the fuel line to the motor? That will remove all restriction. 5/16" fuel connector is very inadequate for a 175HP motor.
  3. C

    1994 mercury mercruiser engine not starting

    Mercruisers have a shift assist switch that kills spark. So, do you have spark?
  4. C

    Shift Interrupt Switch Connection

    A service manual for the newer engine should have one. You probably want one of those anyway, as they are real handy when something like the ignition breaks.
  5. C

    91 Mercury 100 won't run past about 1800 rpm

    Do you have a 2+2 engine?
  6. C

    Possible gimbal bearing noise

    Don't those gimbal bearing have an external zerc fitting? My memory is hazy. They would make noise no matter where the outdrive trim is. Have you been greasing the u joints? They need it every year on the Alpha 1 Gen I outdrive. They could also have water in them. Have they ever been...
  7. C

    Clogged fuel tank vent cause engine to start and die?

    Newer 4 cycle motors have an electric fuel pump. You might wait a couple of seconds after turning the key on for the fuel system to pressurize. Your fuel system might be a positive ventilation type, like in modern autos. These only allow air in, not fuel vapor out. You would need to research it.
  8. C

    Blew my Lower Unit I think (pics included). Need help replacing

    A new standard rotation gearcase from SEI is less than $1000. You will need to see if it will fit your year motor. A new CR gearcase is more like $1350. Again you will need to see if it will fit your year motor. Spray paint is $3
  9. C

    Best Way to Clean Injectors.-

    Gee, the question was whether they need to be cleaned periodically.
  10. C

    Shift Interrupt Switch Connection

    Get a wiring diagram from each engine and compare the wiring to the switch. You can then verify what kind of switch you have. I would expect both motors to have a CDI type ignition, but am not sure of the exact wiring.
  11. C

    Motor runs fine for a bit then randomly slows down then stalls

    Flat primer bulb indicates a fuel restriction upstream of it. That would be tank vent issue or some other restriction. Some tanks have fuel filters in the pickup tube. Most have fuel screens on the tank pickup. Some fuel tanks have dirt that clogs the fuel screen Alternatively, Check the...
  12. C

    91 Mercury 100 won't run past about 1800 rpm

    Did you try pumping the fuel line primer bulb as you accelerate? That will remove fuel starvation (to the carbs) from the causes list. If that fixes it, suspect the fuel pump or fuel filters. Mercury Carbs transition from the idle jet to the main jet at about 1200RPM, however, this can vary...
  13. C

    1989 115hp L6 carb no response to idle screw adjustments

    If you think about it, the piston is at TDC for several degrees, as the crankshaft connecting rod journal turns and the piston reaches TDC. You can see this on any motor. Simply put a screwdriver in the spark plug hole and set the motor to TDC. Now rock the flywheel both ways and see that the...
  14. C

    Motor runs fine for a bit then randomly slows down then stalls

    Pump the fuel line primer bulb. if that fixes it, you have a restriction in the fuel or a weak fuel pump. Is the fuel tank vented?
  15. C

    Blew my Lower Unit I think (pics included). Need help replacing

    Gee, I expect a new gearcase from SEI would be $1K or less. You are willing to pay $1K or more for someone to paint it white?
  16. C

    Repair 1984 forward controls for 115 I6 mariner

    The lock mechanism is usually a simple lever with a spring. The spring is usually inside the handle itself. Maybe item 13 or item 15 are the springs? hard to tell.
  17. C

    1989 115hp L6 carb no response to idle screw adjustments

    If the above checks don't fix it, check the color of the spark plugs. if the bottom ones are real clean, you have water infiltration putting out your spark.
  18. C

    System check lights off but horn on

    A Service manual will provide an electrical check on the sensors. In a nutshell, if you pull the connector off the system check tachometer, you can check the sensor wiring, Check the tan/yellow, tan, tan/orange and tan/black wires for continuity to ground. Any continuity to ground will set...
  19. C

    1991 mercury 150 outboard black max

    Great, tell it to the Mercury OB forum guys/gals. They will want numbers, though.....
  20. C

    Blew my Lower Unit I think (pics included). Need help replacing

    Gearcases can be rebuilt. There may be some professional rebuilders, who will sell you a rebuilt, and take your trade. Ebay will sell you a parted out motor part. It will be used to some extent, extent unknown, care unknown. I would price used and see how lucky you feel. Painting a...
Top