Search results

  1. R

    V4TL-13A Compression Validation

    Install a complete seal kit in the lower unit.
  2. R

    Fuel problem

    Check exhaust cover gaskets.
  3. R

    how to break in a rebuilt 60 hp Merc 2 stroke ?

    You paid $4700 to have this motor rebuilt ???------Way too much too spend in my opinion.----Your general location ?
  4. R

    Suzuki DF115 starting advice

    Stop-----Get a control box hooked up.-----It is a fuel injected motor.----It has an ECU / EMM that needs a power supply.-----Ignore your local " someone " on this motor.
  5. R

    1966 Evinrude 60653 60 HP 4 cyl Vtwin

    Agreed.----Look at pistons / rings via the bypass covers.----And don't worry about head bolts.-----And the heads are warped.----They all are after 50 years of service.----Refinish the heads before installing them with new gaskets.
  6. R

    Help! Water between hull and deck??

    Get a couple of those round inspection ports.-----Remove seats on either side.-------Cut a holes in the floor.----Inspect foam core right down to the hull.------Install inspection ports.----Install the seats.
  7. R

    88 75hp won't stay running

    Open low speed mixture needles 1/8th turn at a time and test run.
  8. R

    Still stuck with with no spark

    I am not there to see or hear your motor.----Do the following.----Charge the battery.-----Load test the battery.----Take starter apart for inspection and ohm test.-----If the motor cranks slow there will be no spark !
  9. R

    V4TL-13A Compression Validation

    Great rugged motors !!----Have one myself here.-----Have a rare short ( 16" ) lower unit that I might install on a 1960 Leavens 15' boat with wings.
  10. R

    1986 75hp Mercury 4cyl shop manual

    Install a new water pump impeller.-----Great motor if in good condition and looked after.-----Wise move in tossing out that 3 cylinder 650 model !!
  11. R

    1966 Evinrude 60653 60 HP 4 cyl Vtwin

    I thought that was a V-4.-----What information do you need?----List the specific details.
  12. R

    V4TL-13A Compression Validation

    Remove the bypass cover and inspect before ordering any parts !!----I remember friends with the 66 model METEOR.------Lots of weekends it would hardly cool down.----Pulled 2 skiers on slalom skis in deep water starts and 17' boat.----It survived brutal punishment.-----Lots of used parts...
  13. R

    Compression Test without a battery?

    You hook up a positive 12 volt cable to the solenoid.----You hook up the negative to the block.----Use the remote starter switch from 12 volt battery to one of the little terminals.----Push the start button and motor should crank .-----But 12 volts and wires can be a challenge to understand.
  14. R

    V4TL-13A Compression Validation

    Pistons / rings are available in 0.020" and 0.040" oversize if you need to repair the one cylinder.
  15. R

    Anyone have Suzuki DT85

    Figure #10 looks correct to me.
  16. R

    Little league world series

    Great competition for kids from all over.-----Often with help from deep pockets.----Parents or local sponsors / fund raising.----Too bad for Canada.-----But for these kids it is a big lesson in life.----" When you go looking for competition , you can find it "
  17. R

    Are wheel locks the way to go?

    move to a better neighborhood ?
  18. R

    V4TL-13A Compression Validation

    Those are just an excellent / simple / reliable motor.----Bullet proof electric shift lower unit.-----The 1966 battery / coil / points distributor can be retrofitted.-----I would remove the bypass cover to look at pistons / rings.----Possible a blown head gasket.----Your location ?
  19. R

    100% Complete Newbie Question about Houseboats

    Are you aware of how much it would cost in fuel ??
  20. R

    1996 - Johnson Outboard - Difficulties Starting But Runs Great

    Good luck with your motor.
Top