Search results

  1. B

    Weight rating for swing tongue?

    Is there a weight rating on a bolt on or weld on trailer swing tongue assembly? I have been contemplating adding a swing tongue assembly to my trailer tongue to save storage space but was wondering if there was a weight rating on them. I have not seen one stated . My boat and trailer weigh...
  2. B

    Winterizing without adding new oil until Spring?

    Is it harmful to your engine to put your boat(and engine) in storage for the winter without adding new engine oil? With all other winterization steps done, old oil pumped out, antifreeze added and pump impeller removed, is it OK to wait until spring before adding the new engine oil at that time...
  3. B

    SX Trim Guage Adjustment

    The trim guage position indicator on the boat does not coinside with the true position of the lower unit on my SX-M drive. When unit is fully down the guage only reads 3/4 down. How difficult is this to correct, can it be done without alot of special tools?
  4. B

    Trim Motor Bracket Replacement

    Hey guys, need some help. The power trim pump bracket for my 5.0 gxib engine, sx-m outdrive has rusted through on the bottom, where it attaches to the inside hull within the bilge area. I have scoured the internet trying to find a part number but can`t find anything. Anybody got any suggestions...
  5. B

    Gelcoat questions

    I have a few scratches/gouges to repair on my boat. What is the best type of gelcoat to work with. My experience in the past with these repairs is that the gelcoat was difficult to work with because it was too runny and drippy. Do they make a gel coat that is a little more putty like that can be...
  6. B

    Whats the best way to remove old letters?

    I just purchased a new set of lettering for my Chaparral, both sides. What is the best way to remove the old letters from the boat without doing any damage to the boat and little damage to the letters? They are raised chrome plastic stuck on with two sided tape. Will a heat gun and scraper be ok...
  7. B

    Water Temp Sending Unit

    I need to know if anybody knows where I can find the part number for the water temp sending unit for a 5.0GXi-b motor . I also need the website of a vendor for such a part. I`ve got temp issues and am considering replacing everything until I find the casue. Thanks.
  8. B

    Volvo Prop Lock Suggestions

    Thinking about adding a Prop locking device to protect my stainless prop on my SX drive `02 volvo. Any suggestions about a good brand that will fit this style of unit?
  9. B

    5.0 GXI-B Wont get up to temp

    Took my Chap out for its inaugrial run this weekend. Everything worked well except for the fact that The engine would not get to normal operating temp (160). It hovered around 120 all day. Prior to this season I had replaced the thermostat and the raw water pump. The temps were verifiyed with an...
  10. B

    SX outdrive oil fill

    Can I refill my 2002 SX outdrive with new oil from the top of the unit in the hole where the dip stick goes and fill until it reaches the level of the mid unit vent screw hole. I`ve been told yes and no. Seems logical that it would work, obviously checking the final level with the dip stick.
  11. B

    Restoring Sticker Shine

    My boat has a bow to stern black stripe sticker running down both sides that has become somewhat faded and cloudy looking in areas. Is there a product or home remedy that will restore this stripe to near new appearance?
  12. B

    Dry pump startup

    I`m getting ready to de-winterize and start up my 5.0gxib engine tomorrow with muffs. I have replaced my raw water impeller and the pump housing is dry except for the glycerine lubricant supplied in the impeller kit. I have read several posts of burning a new impeller on a dry start. Is there...
  13. B

    What type of tandem axle trailer jacks do you use?

    What type of tandem axle trailer jack does everyone use. I have yet to find one that works well or as advertised without some problems. I have used a bottle jack, but found out the hard way that when the tire is flat, it is too tall to get under the axle close to the wheel. I purchased a plastic...
  14. B

    Is it time to replace engine ignition parts?

    Hey guys, need your input. Last summer purchased an `03 Chaparral 243 Sunesta, Volvo 5.0 gxib engine with approximately 400 hours on it. When I put her away for the winter, she was running strong, no problems. I was putting together a spring cleaning list for the boat and wonder if I should...
  15. B

    New Floor Coverings

    I`m thinking seriously about adding new floor coverings and padded swim platform to my Chap before this boating season. I have decided to go with the foam rubber matting rather than traditional carpet. I have reviewed the Sea Dek products and those by Hydro turf. Are there any other similar...
  16. B

    Dual Purpose Batteries, a good idea?

    Before boating season this year, I will need to replace one of the two batteries in my boat. I have a deep cycle and a starting battery set up wired through an A/B switch. The deep cycle battery has a bad cell and needs to be replaced. I was at the store the other day checking prices and saw...
  17. B

    Those Darn Squirrels

    I live in a wooded area and store my trailer in a carport built in the back yard. I noticed over the weekend that squirrels, for the second time, have chewed my trailers electrical wires in two. The wires are encased front to back in black plastic loom but even that did not stop the squirrel...
  18. B

    Second Braking Axle Hydraulics

    I`m working on adding a second set of disc brakes to my trailers back axle. The front axle is already disc braked. I have looked into purchasing calipers and rotors and that part seems pretty straightforward on adding to the rear axle. My question is how are the hydraulic lines ran to the new...
  19. B

    Best Boating Magazines

    Just this year got back into the boating world this year after many years of being away. I would like to subscribe to a good boating magazine or two to enrich my knowledge (along with this Forum) on boats and equipment. What magazines do you guys like and suggest. Being in Indiana, I am not that...
  20. B

    Adding a second braking axle.

    I have a `05 Rocket tandem axle aluminum trailer with surge hydraulic disc brakes on the front axle. For safety measures I have kicked the idea around of adding a second braking axle on the rear. What is involved in doing this and how complicated a proceedure would it be to do. I am fairly...
View older results
Top