Search results

  1. C

    2012 4.3L TKS removal form boat

    Have to pull my motor out of my boat. Are there any manuals online that can guide me on this endeavor. Some how my cylinder wall is gouged. Can’t seem to find any broken or cracked parts that could have caused it. Anyone have any pointers. What need to be removed in the transom? Think I hear...
  2. C

    Service Manual #25 in PDF form

    Hello! I am looking for a link to the Mercuriser Service Manual #25 for my 2012 4.3L TKS engine and Alpha one GenII out-drive. Anyone have a link in PDF format? Problem I am having is that I don't have Flash Player on my office computer and I cannot install it! Thanks
  3. C

    2012 Mercury 4.3 TKS Temp gauge dropping out

    Hello all. Been a while since I’ve been on the Forum. Well I just picked up a 2012 204 FSX Monterey Bow rider only 200 hours Beautiful boat. So here’s my issue... while cruising at slow engine Rpms. Less then 3000. Everything is fine. Once I increase RPM above 3000 the temp gauge drops to 100...
  4. C

    1968 Sea Ray 3.0L Hard Restaring

    Good Morning, My 1986 Mercruser 3.0L 140 has a hard time starting after sitting for half hour to and hour. Runs great first time it is started for the day fires right up. I will tube the kids for an hour, so motor is nice and warmed up. We stop for a half hour or an hour and go back out. When i...
  5. C

    3.0L Alpha1 Gen1 Runs like crap. Hard getting over 2000 RPM

    Well, here I sit up north with 5 kids wanting to go tubing. Boat ran great for about an hour then it crapped out. Couldn't get over 2000 RPM. History: First time on the water this year. last Fall did a full tune-up. Cap Rotor, plugs wires, oil change, gear lube change. this spring I did the...
  6. C

    Merc 3.0L no spark at coil.

    Thanks all in advance for your responses! 1986 3.0L Merc 140. Has no spark at Coil. I stored for winter just uncovered and charged battery. cranked motor and no fire or sputter, checked fuel and it is squirting for the carb so assume it is not a fuel issue. Put my spark tester across the #1...
  7. C

    1986 Sea Ray 3.0L 140 MMC Carter Fuel Pump Problem

    CARTER FUEL PUMP ISSUE!!! Just installed a tune up kit on my 1986 MCM 140 4 cyl. I changed my Filter in my pump and now it will not draw fuel from the tank! also replaced the fuel line from the tank to the pump. Any ideas??? I dont think it is the check Valve in the tank. I tried to draw fuel...
  8. C

    5 wire to 4 pole trailer plug????

    I am baffled at the fact that my trailer has 5 wires going into a 4 pole plug??? Colors: Green (Right, brake light); yellow ( Left, Brake light); then i have 2 black wires and white ( trailer ground). I plug my standard 4 pole tow vehicle plug into it and all i get is the right turn...
  9. C

    3.0L Apla Gen 1 Stalls when shifting to Forward or reverse after Bellow replcaement.

    Hello all, Thank you in advance for your responses! 1986 16' Sea Ray MCM I/O 140 4cyl. 181 CID S/N A394995 MerCarb 2bbl (1 idle adjustment screw) Block S/N 2770087 2 85 Alpha 1 Out Drive S?N A530190 I just recently changed the bellows on my Sea Ray. Put the lower unit back on bell housing...
  10. C

    Bell Housing Removal to do bellows Alpha 1 Gen 1

    OK whats the trick to removing the bell housing on an Alpha 1 Gen 1 outdrive! Have the outdrive off, now need to remove bell housing!!! Help please.
  11. C

    Trim stuck up

    Hello all, Thank you in advance for your responses! 1986 16' Sea Ray MCM I/O 140 4cyl. 181 CID S/N A394995 MerCarb 2bbl (1 idle adjustment screw) Block S/N 2770087 2 85 Alpha 1 Gen1 Out Drive S?N A530190 History, This boat sank last year. just the transom was under water for about an hour. I...
  12. C

    3.0L MCM 140 Boat will not start!

    Hello all, Thank you in advance for your responses! 1986 16' Sea Ray MCM I/O 140 4cyl. 181 CID S/N A394995 MerCarb 2bbl (1 idle adjustment screw) Block S/N 2770087 2 85 Alpha 1 Out Drive S?N A530190 It all started when the Boat sank last year after the shift cable bellow sprung a...
Top