Search results

  1. Faztbullet

    1999 40 hp 2-stroke oil leak

    The oil tank not venting will also cause this, as when sun heats up cowling the oil expands and pushed thru oil pump. The check valve sis overpowered and fills carbs
  2. Faztbullet

    Spark plug

    You have a small water drip from the t-stat/poppet or water jacket onto plug
  3. Faztbullet

    Constant high pitch alarm?

    Motor has to have a t-stat or restriction washer or it will overheat. "P" is a water pump indicator, doesnt mean it cooling.
  4. Faztbullet

    Johnson vs Merc

    Depends on what you are going to use it for and type hull
  5. Faztbullet

    Merc 650 prop shaft seals

    Yes dog needs replaced
  6. Faztbullet

    Unknown port

    Starboard side of looper v-4/6 and for water pressure gauge
  7. Faztbullet

    Loss of power, won't plane

    The WSM bearing will be fine as all the newer engines use the captured style. I have installed several hundred (no joke) of these in rebuilds over the years and never had a issue. BRP, Johnson,Evinrude,and just about every jetski uses these style bearings. Yamaha has used them in all their...
  8. Faztbullet

    Does the Lower engine mount wear out?

    Fixed many just by tightening as they do work loose. I would try this first.
  9. Faztbullet

    Loss of power, won't plane

    Use engine assembly or tranny assy grease only as petro/heat will dissolve it nearly instantly. That grease is for wheel bearings!!!
  10. Faztbullet

    1988 V135 Reeves timing method vs the Merc book?

    Been setting em up for years this way...even EFI. Just unsnap throttle arm to roller, set timings, screw rod in or out to get correct gap to roller. Yep super easy if you let motor tell you want it wants
  11. Faztbullet

    is my CDI supposed to do this? 2001 4 stroke 90hp mercury

    It has a bad solder joint internally
  12. Faztbullet

    94 mariner 150 hp efi

    Make sure plate is grounded and rect/reg is rated for 20amp
  13. Faztbullet

    Mercury Lower Unit Compatibility

    Yes but you will need to update shift linkages
  14. Faztbullet

    1988 V135 Reeves timing method vs the Merc book?

    Set it at 21° while cranking, loosen carb linkages, adjust idle with primary to 1100 rpm on hose, set roller to arm gap at 3/32, check WOT stop and adjust if needed. Good to go
  15. Faztbullet

    94 mariner 150 hp efi

    Was rect/reg plate grounded?
  16. Faztbullet

    1999 Johnson 115 Fuel Leak from “vapor pump”

    Not the vapor pump...float is stuck down in separator
  17. Faztbullet

    94 mariner 150 hp efi

    Did you check spark while in water?
  18. Faztbullet

    Thoughts on aftermarket switchboxes...

    Amazon chinesium junk..Use either the Serria,Merc or WSM , I use Serria as a dealer and they have best warranty
  19. Faztbullet

    94 mariner 150 hp efi

    Need to test it in water as it will rev without a load to 6k on 3 cylinders
  20. Faztbullet

    1993 200 Xri 0D222728 Lower Unit Compatibility

    No EFI that I know of had the small gearcase
Top