Search results

  1. BWR1953

    Welcome Back!

    Woohoo!
  2. BWR1953

    I have returned... with a Starcraft this time!

    After turning the interwebz upside down and shaking vigorously, I was able to find a 2" tach to fit the KF dash. I actually found a needle in a haystack. Finally! :p But! Although I received it in the mail today, I won't be able to install it for another two weeks. That's because the tach...
  3. BWR1953

    Some good stuff happening

    Well, it's been 2 1/2 years since my last post on this project. No real changes have happened since then, but change is definitely acomin' now! :D My young neighbor friend who installed the electric, CATV and internet for me came over this evening to repair the Ethernet cable that runs out to...
  4. BWR1953

    I need a small in-dash tachometer

    While checking on the info provided by you good folks, I happened upon this one which might be the proverbial needle in a haystack. It's 12-pole only but has NO instructions. :eek: However, it has 4 wires: red, black, blue and gray. Positive, negative, light and tach signal from...
  5. BWR1953

    I need a small in-dash tachometer

    :D
  6. BWR1953

    I need a small in-dash tachometer

    Hmmm...
  7. BWR1953

    1982 Starcraft Center Console 18' Rebuild

    If you use this paint, it likely won't perform well unless you use the hardener. And the hardener requires serious Personal Protection Equipment. Namely Positive Pressure face mask, etc. That kind of equipment is pricey. A normal respirator isn't enough. I wasn't willing to shell out $1500...
  8. BWR1953

    I need a small in-dash tachometer

    I've been seriously thrashing the web for a 2" diameter tach which can mount in my dash and work with a 2-stroke motor. So far, no joy. I've found a few automotive tachs which would fit, but can't handle 2-stroke engines. There is very limited space on the dash for the tach. I suppose I...
  9. BWR1953

    I have returned... with a Starcraft this time!

    This morning I had to remove the new Voltage Regulator... Again. :rolleyes: I forgot to install the Thermal Paste on the rear yesterday. :facepalm: It took awhile, but I got it done. :cool: Then I adjusted the carbs to get the engine idle RPM into spec at 600 - 700 RPM, after a 10 minute...
  10. BWR1953

    I have returned... with a Starcraft this time!

    I did get a new ground strap fashioned today and installed it to the regulator with washers as shims behind. Didn't have time to test the engine today but am planning on doing that tomorrow morning. I used 10 ga. wire but trimmed one end to accommodate a smaller connector on one end. Then I...
  11. BWR1953

    I have returned... with a Starcraft this time!

    Yessir, we did. And the voltage was rapidly, wildly fluctuating from nearly zero up to 16vdc. I think that the regulator has an insufficient grounding point. I'm going out to the garage in a few minutes to construct a grounding strap for it so that the connection is really solid. Check the...
  12. BWR1953

    I have returned... with a Starcraft this time!

    Today's progress: Wiring organized! :D Then this: I'm starting to feel like this! :lol:
  13. BWR1953

    I have returned... with a Starcraft this time!

    After weeks of interruptions, the boy and I were finally able to get back to work on the Mercury yesterday. Made some progress too! :cool: YESTERDAY: The old OEM stator next to the new aftermarket one. The OEM unit definitely looks better built. And we had to deal with the wiring too...
  14. BWR1953

    I have returned... with a Starcraft this time!

    WTH is this? It's on the switchbox and it's covered with a rubbery surface. :noidea:
  15. BWR1953

    I have returned... with a Starcraft this time!

    What kind of grease is this? Dielectric grease? Thermal paste? It's on the connector from the old stator to the switchbox. Is it for corrosion protection or something else? What should I use? :confused:
  16. BWR1953

    Time for a new laptop.

    I typically “jump in” to learn about recent tech when I need it, then I buy it and get back out. I generally don't stay up to date. Such is the case now. :cool: I prefer Windows. My current laptop is a Dell e6500 running Windows 7, which was built in 2008 and which I purchased used 3 years...
  17. BWR1953

    Cutting cable TV

    My cable bill has gotten to be ludicrous in cost. It’s gone up over 150% since Spectrum took over several years ago. :mad-new: My current bundled CATV service: No premium channels. Whole house WiFi. Whole house DVR Three cable boxes, including 1 DVR. Landline phone. 100MBPS internet My TV...
  18. BWR1953

    I have returned... with a Starcraft this time!

    One more delivery tomorrow and I'll be able to begin working on the motor. Again. :rolleyes:
  19. BWR1953

    Covid-19 Heat Resistance

    I'm going in! :lol:
  20. BWR1953

    I have returned... with a Starcraft this time!

    Well, I found the yellow/red stripe wires. :rolleyes: I guess it's time to buy a new stator. Looks like this one is 16 years old anyway. I'll go ahead and order a new rectifier too, just because. :facepalm:
Top