Search results

  1. Faztbullet

    1994 Mercury 40HP 2 stroke outboard overheating

    2 different motors....2 different cooling systems. Need to start your own thread buddhapi
  2. Faztbullet

    96 johnson 150

    If you use NGK the correct ones are BPZ8HS-10 and Champion is QL78YC. Which 3 plugs are not firing as motor has a ignition cutout switch?
  3. Faztbullet

    Please help.Motor keeps locking???

    The Merosil block does NOT like to run hot as it starts to shed silica which scores the cylinders. If you lugged engine while pulling boat you could have damaged cylinders or lost a exhaust plate gasket, which would allow water in cylinder and hydrolock it. Either is bad
  4. Faztbullet

    Won't acccelerate

    Ahhhhh...it a dealer warranty as they dressed out the new powerhead. Just moved the problem from original to the new. If it a mechanical issue Merc or a reputable reman company will have to warranty it.
  5. Faztbullet

    Won't acccelerate

    Even if its NOS at a dealer, warranty begins when sold unless dealer/MFG policy's have changed over the years.
  6. Faztbullet

    4.3 mercruiser vortec issue

    Are the rockers installed and correctly torqued? These are non adjustable!
  7. Faztbullet

    89' johnson 90 not charging

    If the rect.reg has a purple wire , make sure you have battery voltage on it with key on. as this turns rect/reg on to operate
  8. Faztbullet

    1996 Evinrude Intruder 175GLED

    Check voltage from org wires from stator to pack
  9. Faztbullet

    Mercury 135 not running

    Most likely cause was the idle stablizer/advance box. Chunk it and set max timing at 21°. A single cylinder running lean is a timing/fuel (carb) problem
  10. Faztbullet

    No spark on half the motor!

    More likely its bad stator, flip the brown connectors from stator to oppisite sides
  11. Faztbullet

    Another Charging issue...

    Yer good
  12. Faztbullet

    Another Charging issue...

    Its only a 16amp output @ 5K RPM, 1/2 that at 2500 (8amp) and 1/2 that at above idle RPM (4 amp) and the new style rect/reg will charge slower at lower RPMS.
  13. Faztbullet

    No spark on half the motor!

    Switch on only loopers
  14. Faztbullet

    Engine oil kit - first time

    Big difference between a 2.6 Inline 6 and a 3.4 V6 and Verado will have the decal
  15. Faztbullet

    Engine oil kit - first time

    Wrong kit as that for Verado motors, you need the below... https://www.wholesalemarine.com/mercury-v6-v8-4-stroke-oil-change-kit-8m0187621/
  16. Faztbullet

    1985 Johnson 120hp poor idle/starting

    The small bores where briged port engines and bad about scuffing exhaust side of piston. Tis resulted in low crankcase compression to drive fuel pump and pull a smaller F/A mix. Also your carbs are fixed jet so no adjustments
  17. Faztbullet

    Johnson engine family

    You have a 2003 White Johnson and only powerhead parts from 2001-2006 60° carb engines will fit. 1991 and up V6 gearcases will interchange with a driveshaft/shift rod swap
  18. Faztbullet

    Water testing new to me 115 HO Etec, and Prop size.

    Totally 2 different engines. The 2009 was a 60° looper design and the 2019 is the 3 cylinder G2 series. It should have the V6 diameter lower unit and will likey require a prop exchange, Now depending on what you are installing it on as performance hull will likely need to go up a pitch. A toon...
  19. Faztbullet

    CDI Electronics and AGM Battery Compatibility

    Factory recommends star (grounding washer) first, then cables and locknut
  20. Faztbullet

    1985 Johnson 120hp poor idle/starting

    Nedd to check DVA output when it dies. Could be a bad connection in stator and when it gets hot, epoxy expands and breaks connection.
Top