Search results

  1. C

    3.0 liter carb problem

    Carb new in 2011? Now it is 13 years later. Pull, clean and rebuild the carb completely, I would recommend. Holley's are good carbs. A rebuild should fix you up. Change the fuel filters, if in doubt about their age.
  2. C

    Is this trailer repairable?

    Johnny, The issue that you identified can easily be repaired, however, if the trailer has more extensive rust, as experience shows us, the best plan is to replace it. Masonry supply and other places have thick and strong angle iron. That could be bolted or welded to fix that one area. That...
  3. C

    New canvas bow cover rolling at edges, solutions?

    If the top is new, I suspect it is not fitted properly. Depending on how you want your relationship with the canvass shop to evolve, you might ask them if they can fix it, or if all their products look this way. Some fabric edges on covers have a stiffener material inside the hem to help with...
  4. C

    No spark on Merc 85hp

    I don't understand "carbs won't spray".
  5. C

    Oil injection delete

    Gee, if you cannot feel the primer bulb (regardless of shape) get hard, you have other issues, IMO. Replace it with a primer bulb you can feel get hard.
  6. C

    Fuel coming out of the hose connected to the vapor pump 0433352

    If the motor runs on some fuel sprayed in the carbs, the carb idle passages/jets are likely clogged. Your motor has the idle passages and needle in the throttle body. There are covers on the sides of the throttle body, which can be removed exposing the idle mixture needle. I used some gumout...
  7. C

    1978 mercury outboard

    A 1978 Merc 115HP will have a battery powered CDI ignition with a single coil and distributor and 6 cylinders. I would recommend you verify this as years of motors get mixed up all the time. 1979 1/2 saw the changeover to 6 coil distributor less ADI ignition. Jumper the starter and take a...
  8. C

    How to choose an old 2-stroke 150/175 Merc

    Yes, I had a 360cc enduro dirt bike some years ago. She had real good power at all RPMs, but if you kept the RPMs near redline as you accelerated, the power was incredible. Of course, with the dinky electrical system she had, you would melt the battery and burn out all the lights at high RPM.
  9. C

    No sparking v4

    Gee, I use torque wrench and wife's bra.
  10. C

    How to choose an old 2-stroke 150/175 Merc

    You can check out the forums on the scream and fly website where they discuss "dry stacking". The thing to remember is that 2 cycle engines like some backpressure at the right time in the exhaust cycle. This is the principle of expansion chambers. With the right expansion chamber, at the...
  11. C

    No sparking v4

    A lot of those Johnnyrudes need the flywheel torqued exactly to the spec, or the key will shear. I would therefore recommend you get the exact torque spec, if you don't already have it.
  12. C

    Fuel coming out of the hose connected to the vapor pump 0433352

    Normally carb overflow is caused by a faulty inlet needle and seat or incorrect flat adjustment, or perhaps a float that leaks and fills up, or jams in the bowl. However, a lot of those engines have plastic carbs. The bowls warp and all sorts of sealing issues occur. The warpage is...
  13. C

    Gas - Oil Mixture on old Evinrudes outboards

    If you have a large tank to premix, it is best to do it in stages. So add a pint of oil, then 6 gal of gasoline, a pint of oil, 6 gal gasoline, until you get close to full. Then 1/2 pint of oil and 3 gal gasoline.
  14. C

    OMC 115 Seaswirl/SeaSquirt TurboJet (1194 115JEERA I think..) Rebuild due to one cylinder filling with gas while cranking?

    Trace the fuel pump hoses, if any, to the crankcase and see what cylinder's crankcase it affects. Some fuel pumps bolt directly to the crankcase. The steel sealing rings on the crankshaft seal the crankcases from each other.
  15. C

    No sparking v4

    Gee, there are a myriad of tools for just that purpose, but sticking a heavy screwdriver somewhere to wedge it works.
  16. C

    OMC 115 Seaswirl/SeaSquirt TurboJet (1194 115JEERA I think..) Rebuild due to one cylinder filling with gas while cranking?

    The fuel pump is powered by crankcase pulses. If the fuel pump diaphragm leaks, the crankcase that powers it often gets raw fuel in it.
  17. C

    Oh no.....wet foam! need a plan B.

    Your boat likely has an aluminum fuel tank. You might inspect it's bottom for corrosion, while you are at it.
  18. C

    How to choose an old 2-stroke 150/175 Merc

    Normally standard dino gear oil is fine for those older gearcases, as that was all there was at the time when new. You might consider synthetic gear oil as the smaller gearcases like yours are a bit challenged by the power of the XR6.
  19. C

    GT 200 fuel pump

    Check out the maxrules web site. They ID them pretty well.
  20. C

    Great Cheap Seat Cushion Cleaner

    Spray 9 is the best. Use some protectant like Armor All afterward.
Top