Search results

  1. C

    Exhaust leak 1989 Merc 60hp

    Engine mounts do not have anything to do with exhaust leaks. They may be bad, but it is unrelated to the exhaust leak. Service manuals only devote a few pages to the midsection, as those repairs are relatively rare. Push and pull on the powerhead and see how much movement is in the mounts...
  2. C

    Surprise My electric car is not charged.

    So your saying that since 8/10 biggest floods occurred before 1976, we do not have sea level rise? Those two items are not related. Also, loosing beach sand has nothing to do with sea level rise or fall. The Jettys on the beach help with that. A lot of people deny science, in this day and...
  3. C

    Exhaust leak 1989 Merc 60hp

    Gee, pulling the powerhead and replacing the gasket takes a couple of hours. It is now April. Why wait 6 months?
  4. C

    Exhaust leak 1989 Merc 60hp

    Likely a leaky powerhead base gasket. It should be fine to use, provided the exhaust doesn't get under the cowling.
  5. C

    2000 Johnson outboard throttle control hanging

    Look for a set screw on the bottom of the handle. You may need to put it into 3/4 throttle in reverse to get to the set screw. Also, pull/slide off the plate with the ridges. You should find some wood screws and some machine screws connecting to the back (guts) of the shifter. Clean and...
  6. C

    4.3lx power steering fluid cooler replacement

    As was said, if she leaks into the bilge, the lines are likely bad. I had to replace the PS lines in my MerCruiser. The metal fittings were zinc plated and rusted out.
  7. C

    4.3lx power steering fluid cooler replacement

    If the PS cooler leaks internally, the PS fluid will leak into the water. You may or may not see it. I would pull it and test it with some pressure.
  8. C

    Stern Drive Mystery

    Engines will rev up just fine in neutral, with dead cylinders, partially clogged filters and antisiphon valves, bad spark advance, bad spark plug wires etc. Neutral testing RPM is meaningless, as it requires little power.
  9. C

    Mercury 115 Tachometer Problem

    Yes, the grey wire is the same as either of the yellow wires. They just pull it thru for convenience. I would not think that the regulator could be good, and the grey wire not putting out the tach signal, however, if that happens, you can substitute either of the yellow wires to get a signal...
  10. C

    Advice for Portable Fuel Tank Mercury 115hp Command Thrust

    Gee, any type of marine fuel tank should work. If using a portable tank on a larger motor, get the largest you can handle, say 12Gal. If you use a quick connect fitting, you need the correct type. On a 115HP motor with a built in tank, I would directly connect the fuel line, and use 3/8"...
  11. C

    96 j150exedb. Water pump

    The drive wedge must be wedged (locked) against the impeller in order to drive it. So grab the impeller, and turn the driveshaft CW to lock it. The wedge is just a solid piece of plastic. If it is not locked, I would think it could be damaged, and the impeller slip. Also, make sure you use...
  12. C

    Surprise My electric car is not charged.

    Gee, I am not sure what those attachments show. What I can say is that the water level in Barnegat Bay, NJ has risen quite a bit in the last 30 years. We now seem to get about 4 or 5 floods a year. 10 years ago it was half of that. 30 years ago, we had hardly any floods.
  13. C

    Starved for fuel

    Depending on year, MerCruisers had mechanical or electric fuel pumps. What do you have? They normally do not have primer bulbs.
  14. C

    Transom

    There are lots of videos on utube showing transom replacement. You might watch a few and get an idea what is involved.
  15. C

    Surprise My electric car is not charged.

    Around here the electric utilities sell backup generators. So if they screw up, you still have juice, and they make more $$. Gee I wish I could have made more money when I screwed up in business! On a related rant. I needed to raise my dock for the second time, as it was under water for a...
  16. C

    Seat covers

    Marine stores do sell them. There are not a lot of styles, however. Check Overtons, West marine and Amazon
  17. C

    Starter fluid everytime....

    It is doubtful that the ether damaged your engine. When the engine doesn't start, a 50::1 fuel solution is in the engine. Actually a lot of the gasoline has evaporated leaving the oil. As was said by post #12, a short a blast of ether will not harm a 2 cycle engine.
  18. C

    Advice for Portable Fuel Tank Mercury 115hp Command Thrust

    Makes sense for the timeframe. No pressure tanks on 115HP motors, right?
  19. C

    Advice for Portable Fuel Tank Mercury 115hp Command Thrust

    Gee, pressurized tanks were on the old Johnnyrudes, say mid 50's. By 1958 my Johnny Fat-fifty had a fuel pump and a regular fuel tank. I do not know if Mercury ever used a pressurized fuel tank. I would be surprised if Mercury made a 115HP motor with a pressurized fuel tank.
  20. C

    Trilobe Pin

    There look to be at least two different PTT systems you can have on that motor. The three ram PTT system should have the trilobe pin. The single ram PTT system doesn't. What do you have?
Top