Search results

  1. R

    Johnson 115 Lower Unit Water Pump Tube

    It seems the extra long models have a different set-up than long models.----If I had the parts in front of me it might be easy to figure out.---I have some long models to look at but no extra long in the shed.-----Sorry.
  2. R

    2000 70 hp

    If a compression test is good it should be last for many years.----Install a new water pump impeller if you become the proud owner.
  3. R

    2000 70 hp

    I have to agree , the 3 cylinder 49 cube motors built to 1988 were simple and rugged.
  4. R

    Johnson 115 Lower Unit Water Pump Tube

    Model # of the motor ?-----You are sure it is not mounted on the water pump housing ?
  5. R

    Outboard motor weight

    Put a 90 HP 2 stroke on it.----Comes in at 300 lbs.
  6. R

    water leaking

    There is a hole covered by top part of the recoil.-----Maybe just needs a new gasket there.
  7. R

    2000 Johnson 50 hp engine surging

    Hook up a timing light.----One cylinder at a time.------you want steady flashing of the light.
  8. R

    Merc outboard serial number question

    Motor needs to be taken apart.
  9. R

    Merc outboard serial number question

    Looks like pre-ignition damage on #1 piston.-----Or overheating.----Many of these in line six motor need a new impeller every 3 years or so.----Many do not have an overheat warning horn either.
  10. R

    Mercury 9.8hp 110.. fails to get water to cool engine

    You installed the correct factory impeller?----Measured to fit the different diameter shaft on these motors ?----Removed exhaust cover ?-----Perhaps there is a hole in it.
  11. R

    Mercury 9.8hp 110.. fails to get water to cool engine

    Is the water in your test bucket 6" above the impeller ?
  12. R

    Mercury 9.8hp 110.. fails to get water to cool engine

    So you did not inspect the washer at the top of the tube ?
  13. R

    Shift rod length

    They made a 5" coupler for the water tube.----At $50 it sounds like a farmer used a cheaper option.----Might just remove what is there and measure to see if it will reach into the water pump grommet.----You ordered a new short shaft or used ?
  14. R

    Mercury 9.8hp 110.. fails to get water to cool engine

    That is where water is supposed to leak out into the exhaust.-----I suspect and have seen it more than once that plastic washer at the top of the water tube is melted.----Remove powerhead to inspect this.----The replacement factory washer is now a better quality.-----I keep some on hand myself.
  15. R

    1986 murcury 60hp only starts and runs in high idle.

    Post the actual compression values on this motor.----Was water pump maintained ?-----Mixed gas and oil at 50:1 in the tank ?-----If you can repair it yourself it is worthwhile.----If you have to pay $2.00 / minute at a shop it will be expensive.-----You might even have trouble finding a shop to...
  16. R

    Shift rod length

    The model # suggests your motor is or was a short shaft.----Is there a 5" spacer between lower unit and exhaust housing ?------You will need a short driveshaft.----Short shift rod would be 5" shorter than the long shift rod.
  17. R

    Exuast backfires 1976 25hp evinrude

    It is a simple procedure.-----Perhaps you can find a video on U-tube.-----Explaining this to you.
  18. R

    Merc outboard serial number question

    I usually find 3 of the 5 bleed inserts missing !----But I can not inspect your motor !
  19. R

    2000 Johnson 50 hp engine surging

    Model # of this motor ?---I assume a 2 stroke.-------Have you checked the gear oil ?------I know for a fact that these gearcases ( 2 stroke ) are not robust.------See if there are any metal bits on the drain plug magnet !!
  20. R

    No spark on Merc 85hp

    One good battery will do.----Use booster cable directly to the starter to eliminate the cables / solenoid as the culprit.-----Find the issue with the system.----Take starter apart.----Very easy.----Then do an ohm test on armature.------Perhaps replace brushes.----Inspect cables.----Not sure why...
Top