Search results

  1. R

    1978 Evinrude 35 hp water,steam exhaust

    A new purchase always needs a new water pump impeller.----And opening the low speed mixture may help getting rid of the lean sneeze.
  2. R

    1994 15 HP Johnson hard to start and rough idle

    Missing thermostat is a red flag to me.------Correct , no point doing anything until you have compression values.----Post them here.----The 1994 15 HP has bigger displacement beginning in 1993 model year.
  3. R

    Slide hammer puller

    There has been much discussion on how to deal with jammed parts.----I have my own procedures,-------Put your favorite penetrating oil on it and try to pull it out.
  4. R

    Slide hammer puller

    It is an anode !-----Provides protection from corrosion.-----It may require some effort to remove the bearing carrier ( seal housing ) as it appears there has been corrosion.
  5. R

    Slide hammer puller

    ???-----The anode was removed or left out.------Just remove the carrier bearing housing.-----Simple in my opinion unless it is a salt water motor.
  6. R

    Method to repair damaged crank/ flywheel key?

    Good luck with your projects.----Lapping of the crankshaft / flywheel is a standard procedure.----Has been part of outboard repairs for some 50 years , perhaps more !
  7. R

    ‘67 evinrude vs 19?? Johnson

    You just need to know how and where to look to find parts for these motors.-----Big dealers are interested in the " willing to spend "----$10,000 or more folks.-----Often not interested in the DIY crowd where they spend 30 minutes answering questions on a $5.00 sale.
  8. R

    Slide hammer puller

    Try----evinrudeparts.ca------And others online .-------They clearly show the tabs.------Perhaps you have the wrong service manual too.
  9. R

    Slide hammer puller

    Strange.------What is the model # of your motor ?----These are shown in the 1990 parts book I look at !
  10. R

    ‘67 evinrude vs 19?? Johnson

    Lots of good used generators / voltage regulators can be found.-----Join-----aomci----And post wanted ad there.
  11. R

    Slide hammer puller

    There is not much load on the bearing carrier.----Those tabs hold it in position.-----No difference in pulling it out compared to any other carrier.
  12. R

    Slide hammer puller

    The propshaft bearing carrier simply pulls out with a slide hammer ( 1/4 threaded rod ) and will not damage bearings in any way !----Or 2 pieces of threaded rod and a strong back will do it.
  13. R

    Method to repair damaged crank/ flywheel key?

    The fitting of the key and the flywheel tapers is much misunderstood.-----Did a 50 HP motor a while back.----After talking to owner and some quick checks I suspected a sheared flywheel key.------Yes it was and and the tapers had been greased.----No wonder it sheared !
  14. R

    Reattaching an oil pump (and reservoir) too a 2004 Yamaha 50hp 3cyl 2 stroke?

    Motor will run just fine on 50:1 mix.----Plugs , on a motor in good condition do not foul with a 50:1 mix ratio.------But oil / lubrication on 2 strokes is not well understood in my opinion.----Model # of your motor ?
  15. R

    Method to repair damaged crank/ flywheel key?

    Facts.------The key locates the flywheel for proper timing of the MAGNETO.-----The flywheel is driven by the locking tapers.-----Flywheel tapers must be lapped for proper fit contact.---Must be installed clean and dry.------Nut must be torqued to specification.-----So get a new factory key and...
  16. R

    ‘67 evinrude vs 19?? Johnson

    I think you will find that the brackets are the same !!
  17. R

    ‘67 evinrude vs 19?? Johnson

    The 62 to 64 model 28 HP----1965 to 70 model 33 HP----1960 a to 76 model. 40 HP----Your location ?
  18. R

    Help with my 125

    That is the correct part.
  19. R

    Evinrude tell tail not discharging

    A new purchase needs a new impeller !
  20. R

    Too windy?

    About 20 minutes.----Boat was a Contessa 32 , these were studied after the 1979 Fastnet race as none sustained any damage.-------Quite scary when you do not know what the next gust is going to do.------On shore there were pine trees snapped like match sticks. broken 20' above the ground where...
Top